20051204-1 Chrismas Tree Run - Mt Rainier - Mike Stuck in Ditch (1 Mbps).wmv
1540 hits | 10.45 MB | Posted: 12/5/05
Mike Stuck in Ditch
(12/4/2005)
(Posted in: Christmas Tree Run 2005)

20051204-1 Chrismas Tree Run - Mt Rainier - Sledding (1 Mbps).wmv
1169 hits | 1.5 MB | Posted: 12/5/05
Sledding
(12/4/2005)
(Posted in: Christmas Tree Run 2005)

20051204-3 Christmas Tree Run - Mt Rainier.jpg
1181 hits | 101.34 KB | Posted: 12/5/05
GPS Log Map
(12/4/2005)
(Posted in: Christmas Tree Run 2005)

20051210-1 Christmas Tree Run - Mt Hood - Lake Harriet Ducks (WS-HQ).wmv
1185 hits | 3.45 MB | Posted: 12/11/05
Ducks on Lake Harriet
(12/10/2005)
(Posted in: Christmas Tree Run 2005)

DCP_0863.jpg
1084 hits | 41.85 KB | Posted: 12/11/05
Sunset Hwy (Hwy 26) Traffic on the way Home.
(12/10/2005)
(Posted in: Christmas Tree Run 2005)

DCP_0865.jpg
1584 hits | 50.63 KB | Posted: 12/11/05
Shilo Inn Christmas Lights
(12/10/2005)
(Posted in: Christmas Tree Run 2005)

DCP_0866.jpg
1174 hits | 38.29 KB | Posted: 12/11/05
Sunset Hwy (Hwy 26) Traffic on the way Home.
(12/10/2005)
(Posted in: Christmas Tree Run 2005)

20051210 Christmas Tree Run - Mt Hood - GPS Log Map.jpg
1191 hits | 104.81 KB | Posted: 12/11/05
GPS Log Map
(12/10/2005)
(Posted in: Christmas Tree Run 2005)

DCP_0859.jpg
1225 hits | 67.35 KB | Posted: 12/12/05
At Ripple Brook Ranger Station
(12/10/2005)
(Posted in: Christmas Tree Run 2005)

DCP_0874.jpg
1190 hits | 32.1 KB | Posted: 1/16/06
[b]PowerTrax No-Slip Locker[/b]

[b]Symptom:[/b] Frequently, most of the time, would not lock passenger side wheel, and noisy operation when it would.

[b]Cause:[/b] The synchro paddle on the Active Spacer broke off (top center) and the loose pie...
(Posted in: Broken)

DCP_0875.jpg
1012 hits | 34.96 KB | Posted: 1/16/06
[b]PowerTrax No-Slip Locker[/b]

[b]Symptom:[/b] Frequently, most of the time, would not lock passenger side wheel, and noisy operation when it would.

[b]Cause:[/b] The synchro paddle on the Active Spacer broke off (top center) and the loose pie...
(Posted in: Broken)

DCP_0877.jpg
968 hits | 43.42 KB | Posted: 1/16/06
[b]PowerTrax No-Slip Locker[/b]

[b]Symptom:[/b] Frequently, most of the time, would not lock passenger side wheel, and noisy operation when it would.

[b]Cause:[/b] Two of the Syncrho Ring teeth broken off (11 & 1 o'clock) by broken Active Space...
(Posted in: Broken)

DCP_0878.jpg
1219 hits | 52.45 KB | Posted: 1/28/06
Slid Off Firebreak Five Trail by the Rock Garden.
(Stuck) (1/28/2006)
(Posted in: TSF Drive About - Nissan Recovery)

DCP_0879.jpg
1231 hits | 40.43 KB | Posted: 1/28/06
Nissan Pick-Up Half Over the Bank
He's been here waiting for someone to come along since dawn, it's now about 4PM.
(Stuck) (1/28/2006)
(Posted in: TSF Drive About - Nissan Recovery)

DCP_0880.jpg
1180 hits | 47.69 KB | Posted: 1/28/06
Nissan Pick-Up Half Over the Bank
He's been here waiting for someone to come along since dawn, it's now about 4PM.
(Stuck) (1/28/2006)
(Posted in: TSF Drive About - Nissan Recovery)

IMG_0102.jpg
1262 hits | 68.4 KB | Posted: 1/28/06
Nissan Pick-Up Half Over the Bank
I was able to raise some other 4 wheelers on the CB to come pull him out.
(Stuck) (1/28/2006)
(Posted in: TSF Drive About - Nissan Recovery)

IMG_0103.jpg
1259 hits | 69.58 KB | Posted: 1/28/06
Nissan Pick-Up Half Over the Bank
I was able to raise some other 4 wheelers on the CB to come pull him out.
(Stuck) (1/28/2006)
(Posted in: TSF Drive About - Nissan Recovery)

20060128 - TSF Drive About - Nissan Recovery (WS-HQ).wmv
1114 hits | 12.59 MB | Posted: 1/28/06
Nissan Pick-Up Half Over the Bank
I was able to raise some other 4 wheelers on the CB to come pull him out.
(Stuck Recovery) (1/28/2006)
(Posted in: TSF Drive About - Nissan Recovery)

20060304-3 Mountain Mud Fest - Tank Trap (WS-HQ).wmv
1112 hits | 28.97 MB | Posted: 3/6/06
Mountain Mud Fest - Tank Trap
(3/4/2006)
(Posted in: Mountain Mud Fest 2006)

Flex-A-Lite Electic Cooling Fan Model #295.JPG
1991 hits | 50.89 KB | Posted: 4/30/06
Flex-A-Lite Model #295 Electric Cooling Fan
(4/29/2006)
(Posted in: Electric Cooling Fan)

DCP_0895.jpg
1934 hits | 40.44 KB | Posted: 4/30/06
Bottom Mounting Brackets
The bottom mounting brackets carry the weight and sit on the tray under the radiator. There are 4 (3 visible in picture) C shape brackets made of 1/16 x 3/4 aluminum flat stock.
Did not use any of the manufactures supplied...
(Posted in: Electric Cooling Fan)

DCP_0899.jpg
2071 hits | 47.33 KB | Posted: 4/30/06
Ground Connection
The ground connection is made to the factory ground post next to the battery at right front of engine compartment.
(4/29/2006)
(Posted in: Electric Cooling Fan)

DCP_0902.jpg
1959 hits | 59.04 KB | Posted: 4/30/06
Ignition On Signal
The ignition on signal source is obtained from trailer battery charge relay. Connection is made by taping into the wire from underneath the auxiliary relay box. The small red wire is the ignition on signal for the electric cooli...
(Posted in: Electric Cooling Fan)

DCP_0901.jpg
2069 hits | 60.46 KB | Posted: 4/30/06
Fuse Holder Mounting & Connection
The fuse holder is mounted next to the starter relay on the right fender.
The fuse holder is connected to the starter relay positive battery terminal.
(4/29/2006)
(Posted in: Electric Cooling Fan)

DCP_0904.jpg
1940 hits | 52.69 KB | Posted: 4/30/06
Variable Speed Controller
The variable speed controller is mounted on the fan shroud.
Wiring is zip tied to the shroud to keep them away from the fan blades.

The VSC also has overrides for Off, and High. However the A/C compressor negative sign...
(Posted in: Electric Cooling Fan)

DCP_0898.jpg
1936 hits | 57.6 KB | Posted: 4/30/06
Top Mounting Brackets
The top mounting brackets hold the shroud against the radiator core but do not carry any weight and are made of 1/16 x 3/4 aluminum flat stock.
Did not use any of the manufactures supplied mounting bracketry.
(4/29/2006)

(Posted in: Electric Cooling Fan)

DCP_0896.jpg
2300 hits | 63.57 KB | Posted: 4/30/06
Flex-A-Lite Model #295 Electric Cooling Fan Installation.
(4/29/2006)
(Posted in: Electric Cooling Fan)

DCP_0905.jpg
1830 hits | 49.97 KB | Posted: 4/30/06
A/C Compressor On Signal
The A/C compressor on signal is sourced from the pressure switch connector.
Since this is a non critical signal, about 1-1/2 to 2 inches of insulation was removed to allow the bare wire to be sandwiched into the connector. ...
(Posted in: Electric Cooling Fan)

Flex-A-Lite Electric Cooling Fan Model #295 Operation (WS-HQ).wmv
1927 hits | 3.35 MB | Posted: 4/30/06
Flex-A-Lite Electric Cooling Fan Model #295 Operation.
(4/29/2006)
(Posted in: Electric Cooling Fan)

EGR DPF & Duty Cycle.jpg
1398 hits | 60.19 KB | Posted: 7/7/06
(Posted in: Ease Diagnostics)

EGR Duty Cycle.jpg
1441 hits | 66.36 KB | Posted: 7/7/06
(Posted in: Ease Diagnostics)

O2 Sensors.jpg
1348 hits | 71.22 KB | Posted: 7/7/06
(Posted in: Ease Diagnostics)

DCP_0906.jpg
1872 hits | 55.47 KB | Posted: 4/30/06
Temperature Probe
The temperature probe is installed in the radiator core next to the coolant return port (upper hose returning coolant from motor). This is per manufactures installation instructions. We’ll see how well it works and its long term...
(Posted in: Electric Cooling Fan)

DCP_0907.jpg
1865 hits | 51.87 KB | Posted: 4/30/06
Why Conversion To Electric
For improved fuel mileage? You're kidding right. In a 6,000 lb. non aerodynamic vehicle you really think removing a belt driven fan with properly functioning clutch is going to make any noticeable difference? Not a chan...
(Posted in: Electric Cooling Fan)

TPS Sweep.jpg
1139 hits | 51.74 KB | Posted: 7/7/06
(Posted in: Ease Diagnostics)

TPS, MAF, IAC.jpg
1160 hits | 61.17 KB | Posted: 7/7/06
(Posted in: Ease Diagnostics)

DCP_0940.jpg
1905 hits | 56.35 KB | Posted: 7/8/06
Transmission Oil Cooler B&M Model 70264
(7/6/2006)
(Posted in: Transmission Cooler)

DCP_0944.jpg
2338 hits | 69.64 KB | Posted: 7/8/06
Transmission Oil Cooler B&M Model 70264
(7/6/2006)
(Posted in: Transmission Cooler)

DCP_0945.jpg
1341 hits | 60.78 KB | Posted: 7/8/06
Transmission Oil Cooler B&M Model 70264
(7/6/2006)
(Posted in: Transmission Cooler)

DCP_0960.jpg
1325 hits | 33.61 KB | Posted: 7/8/06
Transmission Oil Cooler B&M Model 70264 Connections Into Factory Lines
(7/6/2006)
(Posted in: Transmission Cooler)

DCP_0908.jpg
1466 hits | 53.81 KB | Posted: 7/10/06
2 Big Broncos at Long Beach
(5/20/2006)
(Posted in: Long Beach, WA (2006))

DCP_0910.jpg
1203 hits | 24.62 KB | Posted: 7/10/06
End of beach signs.
(5/20/2006)
(Posted in: Long Beach, WA (2006))

DCP_0914.jpg
1321 hits | 23.12 KB | Posted: 7/10/06
Sunset
(5/20/2006)
(Posted in: Long Beach, WA (2006))

P1010021.JPG
1210 hits | 31.57 KB | Posted: 7/10/06
Driving along the beach.
(by The Heyer's, 5/20/2006)
(Posted in: Long Beach, WA (2006))

P1010025.JPG
1201 hits | 38.26 KB | Posted: 7/10/06
Driving along the beach.
(by The Heyer's, 5/20/2006)
(Posted in: Long Beach, WA (2006))