someones bandaid.jpg
628 hits | 110.88 KB | Posted: 5/17/05
We had a couple times the van did not want to start and the charging system seemed low. i found the ...

tray.jpg
558 hits | 110.3 KB | Posted: 5/17/05
this is where the Aux power line goes to and i decided to pull the tray and clean it. then paint it.

tray in van.jpg
544 hits | 70.73 KB | Posted: 5/17/05
this is another pic of the battery tray in the van. it is all surface at this time.

tray outofvan.jpg
595 hits | 113.95 KB | Posted: 5/17/05
here it is out of the van----that was a pain-someone ran the e-brake cable thu the mount so i had to...

tray painted.jpg
598 hits | 125.57 KB | Posted: 5/17/05
2 coats primer and a couple coats of flat black it looks new again.

old cable.jpg
600 hits | 108.7 KB | Posted: 5/17/05
here is the old pos bandaided cable 6' long.

old cable2.jpg
561 hits | 147.13 KB | Posted: 5/17/05
here is another shot of the bandaid---the AUX wire is not showing but i replaced it too.

old negcable.jpg
570 hits | 148.18 KB | Posted: 5/17/05
While i was there i got a new Neg cable too.This is the old one.

new cables old.jpg
557 hits | 111.15 KB | Posted: 5/17/05
Here is the new cables along with the old neg. i had a set made out of 2 guage welding wire. these w...

new cable2.jpg
585 hits | 113.08 KB | Posted: 5/17/05
this is the new cables in and the new AUX power take off. Much better

new cables.jpg
591 hits | 90.81 KB | Posted: 5/17/05
the neg is 2 pieces i replaced the 1st leg as the rest looked ok for now. it goes from the battery t...

gmcpwrmotor.jpg
597 hits | 79.49 KB | Posted: 7/14/05
The windows went up and down real slow and not at all sometimes. i found a couple versions on ebay i...

gmcpwrmotor2.jpg
578 hits | 91.36 KB | Posted: 7/14/05
here is the side shot

gmcpwrmotor3.jpg
668 hits | 93.28 KB | Posted: 7/14/05
the other side. i was able to swap these out in 15 each side. 4 rivets hold the old in and i greased...

newfan.jpg
2569 hits | 84.18 KB | Posted: 7/5/06
Here is a 3.8 tarus 2 speed fan. $19 at the local junk yard. these have a high and low speed and rea...

newfan2.jpg
1256 hits | 80.19 KB | Posted: 7/5/06
here is the back side of the fan. it came complete as seen in the picture.

newrelay.jpg
1224 hits | 82.2 KB | Posted: 7/5/06
Hereis a continus duty relay. it can handle 80 amps all the time. the fan spikes @ 100 amps at start...

newwiretakeoff.jpg
1183 hits | 85.73 KB | Posted: 7/5/06
I wanted to get some of the wires off the battery. so i picked up a single point power take off. Thi...

new wirerouting.jpg
728 hits | 44.85 KB | Posted: 7/5/06
on the inside i needed to get an ignition on power source. so i taped one of the acc on ports in the...

fancontroler.jpg
2038 hits | 73.57 KB | Posted: 7/5/06
Here is the fan temp power controler. I got it new from Autozone $24. the ignition on wire goes to t...

rear window latch GMC.jpg
705 hits | 87.34 KB | Posted: 8/23/06
here is another rear window latch. they do not last too long.

gmc waterpump.jpg
789 hits | 85.58 KB | Posted: 8/23/06
while replacing the radaitor i installed a new NAPA water pump.

gmc waterpump2.jpg
719 hits | 74.96 KB | Posted: 8/23/06
here is the other side of the box.