IAC Cutaway.jpg
25430 hits | 81.72 KB | Posted: 8/4/05
IAC solenoid valves
Key off, IAC solenoid disconnected, resistance through the IAC pins should be between 6.0 and 13.0 ohms. Resistance from either pin to the case should be greater than 10Kohms.
NOTE: Due to diode in solenoid, place DVOM(plus) lead...
(Posted in: Diagrams)

Dallas Cowboys Body Paint.jpg
25376 hits | 37.81 KB | Posted: 10/3/05
Dallas Cowboys Body Paint
(Posted in: Misc)

Fuel Lines 95 Bronco.jpg
25064 hits | 83.55 KB | Posted: 9/14/05
Fuel Lines 95 Bronco (all EFI similar)
IF THE IMAGE IS TOO SMALL, click it.
Supply (pressure) lines are blue; return lines are gray.

Same as '90-96 single tank gas (& '97 over 8500GVWR)

To temporarily or permanently convert a '90-up 2-tank truck to...
(Posted in: '90-96 Fuel Pump System)

ParkingBrakeCables.jpg
25058 hits | 54.56 KB | Posted: 1/21/06
Parking Brake Cables ('92-96)
IF THE IMAGE IS TOO SMALL, click it.

View Y has been revised - see the TSB linked below.

1 Control Assembly 2780
2 2 Nut M8 x 1.25 Hex Flange 17-23 N-m (13-17 Ft-Lb) N620481-S
3 Cable Assembly, Front 2853 ([url=http...
(Posted in: Brakes & Hubs)

ford 9 inch diagram.JPG
24914 hits | 64.15 KB | Posted: 7/30/09
(Posted in: 9" axle build and install)

Just brought home..jpg
24849 hits | 56.49 KB | Posted: 1/2/11
William Berasis and Da Bronc back in 98.
(Posted in: DLS 414 Stroker)

Wiring84.JPG
24671 hits | 67.6 KB | Posted: 3/15/09
Wiring Diagram for '84 Bronco & F-series (gas).
IF THE IMAGE IS TOO SMALL, click it.

Similar to '80-91 Bronco & F-series (gas).

See also:
http://www.revbase.com/BBBMotor/Wd

[url=http://www.supermotors.net/registry/media/849725][img]http://www.supe...
(Posted in: Diagrams)

Engine Exploded Complete.jpg
24534 hits | 104.47 KB | Posted: 1/2/05
Exploded 4.6L 2V Complete

1 Bolt N806155-S2
2 Fuel Charging Wiring 9D930
3 Accelerator Cable Bracket 9723
4 Bolt N804394-S8M
5 Fuel Injection Supply Manifold 9F792
6 Fuel Injector (8 Req'd) 9F593
7 Nut N806178-S2
8 Water Hose Connection 859...
(Posted in: Diagrams)

EGRTubesV8.JPG
24210 hits | 93.96 KB | Posted: 9/20/10
EGR Tubes for (early; non-PFE/DPFE) 5.0L & 5.8L
IF THE IMAGE IS TOO SMALL, click it.

1 - Exhaust Gas Recirculation Valve 9D460
2 - EGR Valve to Exhaust Manifold Tube 9D477 (4.9L F4TZ9D477C = [url=https...
(Posted in: Diagrams)

TGMotorWiring.JPG
23828 hits | 61.24 KB | Posted: 12/4/08
Tailgate Motor Wiring '92-95 (other years similar)
IF THE IMAGE IS TOO SMALL, click it.

. [url=http://www.supe...
(Posted in: Tailgate Tech)

1992 Bronco frame.JPG
23792 hits | 69.64 KB | Posted: 9/4/06
Bronco Frame Dimensions 1992 (other years similar; '92-96 F150 similar)
IF THE IMAGE IS TOO SMALL, click it.

See also:
https://fordbbas.com/publications

[url=https://www.supermotors.net/registry/media/194329][img]https://www.supermotors.net/getfile...
(Posted in: Diagrams)

08WireRoute.JPG
23496 hits | 71.25 KB | Posted: 1/28/06
Trace the Transmission Control Switch (TCS) wire from the shift lever to its connector, & disconnect it.

The larger black harness is the other clock spring wires, including cruise, horn, radio & HVAC (if equipped).

White shift indicator tubes are V...
(Posted in: Steering Column)

FuelPressureGauge.JPG
23450 hits | 73.98 KB | Posted: 9/18/10
Fuel Pressure Gauge
A Sears/Craftsman gauge costs $35-55, but many parts stores will loan/rent tools like this for a deposit.

This is a '98 4.6L car, but the idea is the same for all EFI vehicles. Some just don't have a test fitting, which makes co...
(Posted in: '90-96 Fuel Pump System)

PCV-EFIs.JPG
23393 hits | 107.41 KB | Posted: 10/8/10
PCV Hoses for EFI engines, EXCEPT MAF
IF THE IMAGE IS TOO SMALL, click it.
The rubber hose connecting the hard plastic PCV vent tube (F5TE6C324AA) to the nipple on the oil filler neck of the valve cover can be replaced with [url=https://www.amazon.co...
(Posted in: Diagrams)

ThrottlePlug.JPG
23366 hits | 47.11 KB | Posted: 4/12/08
Throttle Plate Orifice Plug Service Installation

Some steps in the following procedure reference special tools or equipment, but reading the procedure will still be informative, and should allow proper idle speed adjustments using common tools.

[ur...
(Posted in: Diagrams)

Fuel Tank Bronco.jpg
23152 hits | 60.15 KB | Posted: 1/20/06
Fuel Tank mounting & rollover valves
IF THE IMAGE IS TOO SMALL, click it.

E1TZ-9047-K Tank-to-Neck Filler Hose
F2TZ-9002-M Tank, 32gal '92-96
FOTZ-9002-D Tank, 32gal '90-91
EOTZ-9002-G Tank, 32gal '80-89
D8TZ-9A147-A Skid Plate, 32gal '80-91
D8TZ-9...
(Posted in: '90-96 Fuel Pump System)

sophia rossi 1.jpg
22998 hits | 29.67 KB | Posted: 11/3/08
(Posted in: FSB hottie thread)

FSA05S28SpeedControlDeacSw.JPG
22971 hits | 48.81 KB | Posted: 4/12/07
05S28-Supplement #15
April 10, 2008
Check the Ford website &/or the NHTSA to see if your VIN is a...
(Posted in: TSBs & FSAs (Recalls) for '83-96 Broncos & F150s)

Body Mounts.jpg
22923 hits | 61.26 KB | Posted: 4/8/05
Body Mounts for 1994 Bronco ('80-96 similar; F-series cab mounts similar)
IF THE IMAGE IS TOO SMALL, click it.

The rear bolts (view V) are 7/16"x14(NC) 6.5" long threaded 2.5" with a 5/8" head with large integral washer.
The 6 id...
(Posted in: Body Mounts)

MFS Testing.jpg
22887 hits | 47.47 KB | Posted: 7/17/05
MFS Testing '92-up
IF THE IMAGE IS TOO SMALL, click it.
Upper Connector Motorcraft WPT-611
Lower Connector Motorcraft WPT-179

Use these photos for access...
(Posted in: Diagrams)

58LExploded.jpg
22731 hits | 120.26 KB | Posted: 4/10/08
5.8L Exploded
IF THE IMAGE IS TOO SMALL, click it.

Bore x Stroke: 4.00 x 3.50
Oil Pressure @ 190°F 2KRPM: 275-448kPa (40-65psi)
[url=https://www.supermotors.net/registry/media/768241][img]https://www.supermotors.net/getfile/768241/thumbnail/switchs...
(Posted in: Diagrams)

CruiseE.jpg
22644 hits | 56.16 KB | Posted: 7/3/06
Electronic Cruise Circuit '93-04
IF THE IMAGE IS TOO SMALL, click it.

The Speed Control Servo/Amplifier Assembly uses a servo motor working through a magnetic clutch to move the throttle through the Actuator cable. Diesel trucks from '94.5-up have ...
(Posted in: Diagrams)

ServicePointsGas.jpg
22472 hits | 49.17 KB | Posted: 10/30/05
Service Points for '87-96 gas engines
IF THE IMAGE IS TOO SMALL, click it.
'96 Bronco Maintenance Guide
[url=http://www.fordservicecontent.com/Ford_Content/c...
(Posted in: Diagrams)

RABS Components 92.jpg
22445 hits | 71.26 KB | Posted: 1/13/06
RABS Components ('87-89 similar)
IF THE IMAGE IS TOO SMALL, click it.

The RABS TEST CONNECTOR location indicated may only apply to '92-up; earlier trucks have it beside the e-brake pedal.
Rear axle [url=https://www.amazon.com/dp/B001H1MQFI]ABS sens...
(Posted in: Brakes & Hubs)

DSC01526.JPG
22431 hits | 66.72 KB | Posted: 6/21/09
American Racing Torq Thrust M Chrome 17" x 8" wheels
225/55R17 Tires
(Posted in: June 2009)

4R70WComponents98.jpg
22405 hits | 86.17 KB | Posted: 4/3/05
4R70W Components
(Posted in: Diagrams)

bigbear2.jpg
22144 hits | 60.77 KB | Posted: 7/26/03
(Posted in: Random Pics 4)

Compression Pressures.jpg
21982 hits | 51.04 KB | Posted: 9/25/05
Compression Test
IF THE IMAGE IS TOO SMALL, click it.

1. Ensure oil in crankcase is of the correct viscosity and at proper level and battery is properly charged. Operate vehicle until engine is at normal operating temperature. Turn ignition switch t...
(Posted in: Diagrams)

FPR.jpg
21939 hits | 41.58 KB | Posted: 1/22/06
The fuel pressure regulator (Motorcraft '93-95 Lightning CM4764; '88-95 5.8L CM4760; 5.0L CM4766) is attached to the fuel rail downstream of the fuel injectors. It adjusts fuel pressure supplied to the...
(Posted in: '90-96 Fuel Pump System)

TransStick92.jpg
21928 hits | 74.42 KB | Posted: 11/11/05
Manual Transmissions '92

See also:
. [url=https://www.supermotors.net/registry/media/72405][img]https://www.su...
(Posted in: Diagrams)

Carbon Canister.JPG
21856 hits | 60.54 KB | Posted: 6/10/07
Carbon Canister (aka Charcoal Canister, Vapor Canister)
Motorcraft CX741
Motorcraft W0133-1698805-MTR

The activated charcoal inside the canister absorbs ...
(Posted in: Diagrams)

Clutch ConcSlave.jpg
21806 hits | 40.98 KB | Posted: 9/15/05
Concentric Slave Cylinder 9L5Z-7A508-A Bleeding
IF THE IMAGE IS TOO SMALL, click it.
1. Disconnect the coupling at the transmission with Coupling Disconnect Tool T88T-70522-A or equivalent by sliding t...
(Posted in: Hydraulic Clutch)

SteeringLinkage.JPG
21798 hits | 74.96 KB | Posted: 10/5/06
Steering Linkage for Bronco & F150
VIEW A IS INCORRECT - there is no adjusting sleeve at the pitman arm. The main view is correct.

1 Tie Rod Ball Stud (Part of 3A131) (R has RH threads, MotorCraft [url=https://www.amazon.com/dp/B001FGL58O]MEOE140[/...
(Posted in: Diagrams)

CruiseDiagnosticsElectronic.jpg
21678 hits | 58.21 KB | Posted: 2/12/05
Cruise Control Diagnostics for '93-up electronic servo system
IF THE IMAGE IS TOO SMALL, click it.


Before checking...
(Posted in: Diagrams)

AirbagCircuit96.JPG
21674 hits | 40.25 KB | Posted: 1/6/07
'94-96 Bronco/F-series (under 8500GVWR) Airbag Circuit & Codes
IF THE IMAGE IS TOO SMALL, click it.
ERROR: in the upper diagram, pin 17 goes to circuit 617 (Pk/Or) - not 625 (Y/LG).

The air bag diagnostic monitor (14B056) continually monitors all su...
(Posted in: Diagrams)

EECconnectors.JPG
21650 hits | 110.46 KB | Posted: 10/20/11
'85-96 Bronco & F150 (gasoline smallblock) EEC Pinouts
IF THE IMAGE IS TOO SMALL, click it.
ERROR: '95 pin 54 should say "WOT A/C Relay (CA 4.9L)", & '96 pin 69 should say "WOT A/C Relay (4.9L)"

'93-95 Lightnings use the '84-93 n...
(Posted in: Diagrams)

PlugWires50L.jpg
21285 hits | 59.3 KB | Posted: 7/14/03
5.0L Spark Plug Wire Routing '93-back



Spark plug & coil wires should measure ~7KOhm/foot from the...
(Posted in: Diagrams)

HeaterHose49L.JPG
21036 hits | 88.79 KB | Posted: 5/3/07
Heater Hose Routing for 4.9L
Reversing the heater core hoses (2) AT THE HEATER CORE will not cause any problems, and may help remove debris from the heater core.
To bypass a leaking heater core, disconnect the supply (front, hot) hose at the engine a...
(Posted in: Diagrams)

49LExploded.JPG
20533 hits | 75.17 KB | Posted: 4/4/10
4.9L (300ci) I6 Exploded
IF THE IMAGE IS TOO SMALL, click it.

UPPER sizes:
8's bolts are 8mm (5/16") drive
9's nuts are 27mm
11's bolts are 9/16" drive
14 & 23 are 11mm (7/16") drive
24 & 25's nuts are 11mm (7/16")
46 & 49's bolt...
(Posted in: Diagrams)

TSB97-09-05IAC.jpg
20348 hits | 71.63 KB | Posted: 1/2/07
Advance Auto Parts sells a genuine Ford (Motorcraft CX1835) IAC in a Wells TV266 box for ~1/2 the Ford dealer's price. Check for the Ford PN pin-printed ...
(Posted in: TSBs & FSAs (Recalls) for '83-96 Broncos & F150s)

Dash94-96Components.JPG
20175 hits | 101.73 KB | Posted: 3/24/07
Dash Components '94-96 ('96 DLC not shown, near 24)
IF THE IMAGE IS TOO SMALL, click it.



To find something on th...
(Posted in: Diagrams)

WiperMotorTesting.jpg
20048 hits | 43.02 KB | Posted: 7/17/05
Wiper Motor Testing '92-up
IF THE IMAGE IS TOO SMALL, click it.

W - Lo
DB/O - Hi
Y/R - Ground (motor)
Bk - Ground (park)
Bk/Pk - Position
DG - Power (park)

NOTE: The ground wire test at the top is only for motors that DO NOT RUN normally.
The motor...
(Posted in: Diagrams)

TSB91-25-07IACSludge.jpg
20006 hits | 37.76 KB | Posted: 4/22/09
TSB 91-25-07 IAC Sludge; Poor Idle
Publication Date: DECEMBER 13, 1991

IF THE IMAGE ABOVE IS TOO SMALL TO READ, CLICK IT

FORD: 1983-87 EXP
1983-91 ESCORT
1984-90 MUSTANG, THUNDERBIRD
1986-90 TAURUS
1986-91 CROWN VICTORIA
1988-90 TEMPO
LINCOL...
(Posted in: TSBs & FSAs (Recalls) for '83-96 Broncos & F150s)

TSB95-02-11Shorts.jpg
19783 hits | 85.74 KB | Posted: 1/2/07
TSB 95-02-11 Short Circuits, Common Locations on '94-95 Trucks
IF THE IMAGE IS TOO SMALL, click it.

For other TSBs & free wiring diagrams, check here.

Inspect the vehicle for any aftermarket accessorie...
(Posted in: TSBs & FSAs (Recalls) for '83-96 Broncos & F150s)

FuelLevelWiring.JPG
19607 hits | 78.84 KB | Posted: 7/19/09
Fuel Level Sender & Gauge Wiring for '92-96 Broncos ('87-91 Bronco similar)
IF THE IMAGE IS TOO SMALL, click it.
For '87-96 F-series w/dual tanks, see:
[url=https://www.supermotors.net/registry/media/1126824][img]https://www.supermotors.net/getfile/1...
(Posted in: Fuel Level Sender Repair)