Exhaust5.8L96.jpg
19589 hits | 68.61 KB | Posted: 7/14/03
'96 5.0L & 5.8L F-series Exhaust (except Lightning)

IF THE IMAGE IS TOO SMALL, click it.

Before madly...
(Posted in: Diagrams)

TSB98-5A-4LugTorque.jpg
19531 hits | 80.96 KB | Posted: 2/20/07
TSB 98-5A-04 Brake Vibration / Lug Nut Torque
IF THE IMAGE IS TOO SMALL, click it.

Publication Date: MARCH 18, 1998

FORD: 1972-97 THUNDERBIRD
1976-86 LTD
1976-97 MUSTANG
1981-97 CROWN VICTORIA
1982-88 EXP
1982-98 ESCORT
1984-94 TEMPO
1986-97 TAU...
(Posted in: TSBs & FSAs (Recalls) for '83-96 Broncos & F150s)

RABS Codes 92.jpg
19497 hits | 67.14 KB | Posted: 1/13/06
RABS (& RABS-II) Flashout Codes Chart
IF THE IMAGE IS TOO SMALL, click it.

The possible flashout codes are listed and explained in the Flash Codes Chart. Note that Codes 1 and 16 are not used.

[url=https://www.supermotors.net/registry/media/280872]...
(Posted in: Brakes & Hubs)

BW1356ESOF.JPG
19427 hits | 105.18 KB | Posted: 12/31/06
BW 1356 Electronic Shift-On-the-Fly (ESOF) (F1TA-7A195-DA)
IF THE IMAGE IS TOO SMALL, click it.

The pump stay arm (the triangle in the bottom center inset) is known to wear through the case rib & spin, causing the pump to stop pumping, causing the t...
(Posted in: Diagrams)

Hayneses.jpg
19412 hits | 24.52 KB | Posted: 10/28/06
This red one is a VERY old edition (#880), perfect for '80-86 trucks. It includes many older diagrams not found in later editions. For '87-96 trucks, a [url=http://matveynator.ru/f/95a5b03dea0e72ac31566bc78c7dc009.pdf]red cover that goes to '96[/ur...
(Posted in: General Purpose Pics)

FuelFlow.JPG
19384 hits | 39.46 KB | Posted: 10/14/12
'84-96 fullsize Ford truck EFI Fuel Flow
IF THE IMAGE IS TOO SMALL, click it.

. [url=https://www.supermotors...
(Posted in: '90-96 Fuel Pump System)

EmissionsV8.jpg
18958 hits | 85.69 KB | Posted: 7/23/05
Emissions Components on an '88 5.0L F150 w/AOD

Before madly ripping out all the emissions systems on your vehicle, read this article.

[url=https://www.supermotors....
(Posted in: General Purpose Pics)

FiringOrderI6.JPG
18934 hits | 37.73 KB | Posted: 10/15/09
I6 Firing Order: 1-5-3-6-2-4
Distributor Clampdown 24-33 Nm; 17-25 lb-ft

. [url=http://www.supermotors.n...
(Posted in: Diagrams)

Self-Test.jpg
18926 hits | 23.85 KB | Posted: 7/14/03
Jumper Wire for EEC Self-Test (WPT-743 & WPT-352)




For more info, read the 7th post in this thread:
http://www...
(Posted in: Diagrams)

AC System Function.jpg
18913 hits | 44.6 KB | Posted: 7/24/05
A/C System Function
IF THE IMAGE IS TOO SMALL, click it.

The compressor (4) pulls low-temp./press. refrigerant vapor (11) from the accumulator (3) and raises its pressure & temperature. As it flows through the condenser ( 8 ), the refrigerant's ...
(Posted in: Diagrams)

TSB92-01-08TcaseOperationX.jpg
18776 hits | 46.94 KB | Posted: 4/20/09
TSB 92-01-08 (Excerpt) Touch-Drive ESOF Operation
IF THE IMAGE IS TOO SMALL, click it.
Publication Date: JANUARY 6, 1992

LIGHT TRUCK: 1990 and prior BRONCO II
1992 and prior AEROSTAR, BRONCO, F-150, F-250, F-350, RANGER
1991-92 EXPLORER

ISSUE: For...
(Posted in: TSBs & FSAs (Recalls) for '83-96 Broncos & F150s)

STA71043.JPG
18745 hits | 31.24 KB | Posted: 9/17/07
(Posted in: September 07 quick detail)

TailgateLatchPickup.JPG
18720 hits | 74.18 KB | Posted: 2/12/07
Pickup Tailgate Latch & Hinge
IF THE IMAGE IS TOO SMALL, click it.

1 Clip 382929-S
2 Link 43868
3 Bumper 44482
4 Nut (11mm) and Washer Assembly N621906-S43M
5 Roller 430B58
6 Tailgate 40702
7 Insert 430B44
8 Screw (T50) N804563-S100
9 Tailgate Suppo...
(Posted in: Diagrams)

07Wire.JPG
18657 hits | 60.77 KB | Posted: 1/28/06
Trace the Transmission Control Switch (TCS) wire from the shift lever to its connector, & disconnect it..

The bright yellow wire is from the clock spring. Bright yellow wiring covers are an industry standard to indicate SRS (airbag) wiring.
(Posted in: Steering Column)

Carb1bbl.jpg
18519 hits | 68.51 KB | Posted: 11/19/05
1bbl Carburetor for 300ci I6
IF THE IMAGE IS TOO SMALL, click it.

Common problems include:
1) it's a carburetor
2) because of the design of the intake manifold (log), it's impossible to get the correct mixture to all the cylinders; 3&4 will always b...
(Posted in: Diagrams)

Fittings.JPG
18405 hits | 67.51 KB | Posted: 3/22/05
Close up of tank fittings
(Posted in: Air Bags and Tank)

StarterRelayTerminals.JPG
18372 hits | 64.27 KB | Posted: 7/4/10
My starter relay (E9TZ-11450-B). Functionally identical to the older style whose main lugs point to opposite sides, but a vastly superior design. If the white text labels in the pic are too small to read, click the pic.

Note that the starter wire ...
(Posted in: General Purpose Pics)

FSA89S76FuelLine.jpg
18181 hits | 91.32 KB | Posted: 1/25/07
The NAPA / Wix filter number that includes the O-ring for the reservoir is 3268. See also:
. [url=http://www.sup...
(Posted in: TSBs & FSAs (Recalls) for '83-96 Broncos & F150s)

DSC03504.jpg
18078 hits | 29.72 KB | Posted: 4/18/05
-= This is me at my jump, Its amazing i made a no-footer to a no hander, scarry but yea =-


guys post more! give me more mods i could do!!!! ran out of ideas!
(Posted in: My Jumps)

TSB85-05-26ClutchDiag.jpg
17952 hits | 81.58 KB | Posted: 4/20/09
TSB 85-05-26 Hydraulic Clutch Diagnosis '83-86 ONLY

SYSTEM FEATURES:
* The hydraulic release system is self-adjusting. The slave cylinder has an internal spring which extends the piston against the release lever, provides a "no lash" condi...
(Posted in: TSBs & FSAs (Recalls) for '83-96 Broncos & F150s)

P1010088.JPG
17849 hits | 64.06 KB | Posted: 7/27/05
(Posted in: after SAS, flex pics and misc.)

DCP_2146.JPG
17686 hits | 84.85 KB | Posted: 4/2/04
Underhood toolbox, just move washer bottle to front, shift jack handle
(Posted in: Underhood toolbox)

ACClutchFS6.jpg
17462 hits | 55.02 KB | Posted: 10/26/05
FS6 Compressor
IF THE IMAGE IS TOO SMALL, click it.

Type: swashplate w/3 double-acting axial pistons
Displacement: 10.4 CI
Bore: 1.4"
Stroke: 1.2"
Rotation: CW
Oil (for R-12 Refrigerant): YN-9 (E73Z-19577-A)
System Capacity: 10 fl. oz.
Clu...
(Posted in: Diagrams)

M5ODR2Ex.JPG
17380 hits | 93.15 KB | Posted: 11/8/11
Mazda M5OD-R2 Disassembly
IF THE IMAGE IS TOO SMALL, click it.

M5OD-R2 TRANSMISSION GEAR RATIOS:
1 - 3.90 : 1
2 - 2.25 : 1
3 - 1.50 : 1
4 - 1.00 : 1
5 - 0.80 : 1
R - 3.39 : 1

First Gear
The first/second synchronizer is splined to the output shaft. ...
(Posted in: Diagrams)

DLCjumper.JPG
17373 hits | 53.2 KB | Posted: 4/17/11
This is a cheap & easy upgrade to any EEC-IV vehicle: a simple jumper wire twisted into the harness behind the DLC makes pulling codes or triggering the fuel pump relay quick & convenient. Scratch the terminal identifications into the plastic connec...
(Posted in: General Purpose Pics)

DiffBuilt.JPG
17346 hits | 114.91 KB | Posted: 7/21/03
The guts of a common open differential.

For info about tone ring (E7TZ-4B409-B) damage, see this caption:


For...
(Posted in: 8.8" Axle)

VECI.JPG
17337 hits | 68.57 KB | Posted: 3/24/11
Vehicle Emission Control Information label details
IF THE IMAGE IS TOO SMALL, click it.
The VECI label includes specific engine calibration information, the tune-up procedure (if applicable), the base timing procedure, and the vacuum map. Most of th...
(Posted in: Diagrams)

PSOM.jpg
17242 hits | 54.89 KB | Posted: 11/25/03
PSOM diagram for '96 Bronco. '93-95 Bronco similar.
http://www.revbase.com/BBBMotor/Wd

CHECK SPEED INPUT SIGNAL

NOTE: Only wiring harness end of connector is to be probed.
* Connect Rotunda Digital Volt-Ohmmeter 014-00407 or equivalent to Pin 4 (s...
(Posted in: PSOM)

SecondaryAir50L.jpg
17224 hits | 53.01 KB | Posted: 10/9/05
'87-95 5.0L Secondary Air

Before madly ripping out all the emissions systems on your vehicle, read this article.

[url=http://www.supermotors.net/registry/media/589...
(Posted in: Diagrams)

Flange.JPG
17063 hits | 115.77 KB | Posted: 7/21/03
The '87-up ABS sensor (DY1123, F85Z-9E731-AB) bolt is like the rear cover bolts: 13mm hex head @ 25-30 lb-ft. The sensor's resistance should be 800-1400 Ohms across the pins, and more than 10K Ohms fro...
(Posted in: 8.8" Axle)

Rock Crawler 016.jpg
17016 hits | 64.5 KB | Posted: 12/28/08
(Posted in: RC Bronco Rock Crawler)

rat rod 6.JPG
16774 hits | 66.31 KB | Posted: 6/10/07
(Posted in: Just pics)

DSC05323.JPG
16730 hits | 86.19 KB | Posted: 11/13/08
(Posted in: Misc 6)

FusibleLinkRepair.JPG
16710 hits | 80.11 KB | Posted: 10/12/10
Fusible Link Wire Repair

Ford - - - - - - Standard
- - - - - - - - - - Orange - - - - 22ga. - 0.35mm
Blue - - - - - - Gray - - - - - - 20ga. - 0.5mm
Brown/Red - Blue - - - - - - 18ga. - 0.8mm
Orange - - - - Black - - - - - 16ga. - 1.0mm
Green - - -...
(Posted in: Diagrams)

SecondaryAir58L.jpg
16625 hits | 72.07 KB | Posted: 10/9/05
'87-95 5.8L Secondary Air

Before madly ripping out all the emissions systems on your vehicle, read this article.

[url=https://www.supermotors.net/registry/media/58...
(Posted in: Diagrams)

RecircLine.JPG
16602 hits | 51.24 KB | Posted: 11/9/09
If MAX A/C only blows out the defrost registers, or if it switches to defrost during hard acceleration, or if the doors move after the engine is shut off, this vacuum line (to the recirculate motor) is the reason. The white plastic is far more susce...
(Posted in: General Purpose Pics)

SelfTestSwitch.JPG
16548 hits | 109.61 KB | Posted: 1/26/12
Self-Test Switch for '87-95 EEC-IV vehicles.
IF THE IMAGE IS TOO SMALL, click it.

Not all lighted switches are suitable for this mod. Note that the switch shown is technically a DPST with a shared common terminal, and one pole (terminal #1) wire...
(Posted in: Diagrams)

DLC96BroncoC201.jpg
16502 hits | 35.24 KB | Posted: 2/1/05
OBD-II test connector (Motorcraft WPT615) located under glove box for '96 Bronco with EEC-V processor. For code info, see:
https://www.obd-codes.com/trouble_codes/

[url=http://www.supermotors.net/reg...
(Posted in: Diagrams)

IgSwLogic.JPG
16467 hits | 72.98 KB | Posted: 10/17/10
Ignition Switch Logic Tables '80-96
IF THE IMAGE IS TOO SMALL, click it.
The early '80-91 switch is on the LEFT; the later '92-up is on the RIGHT.

'80-91 Motorcraft SW2472
Battery - Y - 37
Accy1 - Bk/L...
(Posted in: Diagrams)

Love_that_flex!_[2].JPG
16416 hits | 49.55 KB | Posted: 6/30/03
(Posted in: Paulsen Rd.)

eBframexDims.JPG
16401 hits | 63.15 KB | Posted: 7/6/11
Early Bronco Frame Details (based on a '75 wagon frame)
IF THE IMAGE IS TOO SMALL, click it.
Frame Thickness ~0.120"

I still have to make a few corrections & additions, but it's basically complete & much more accurate than any previously availa...
(Posted in: Tech Diagrams)

AirFilters.JPG
16395 hits | 82.78 KB | Posted: 9/18/10
'87-96 Air Cleaners Motorcraft FA1046 K&N 33-2023
IF THE IMAGE IS TOO SMALL, click it.

Top 2 are MAP (speed-density) '87-95; bottom 2 are MAF '94-96.
Le...
(Posted in: Diagrams)

Vacuum 93 5.8L.JPG
16363 hits | 59.43 KB | Posted: 7/14/03
Vacuum Routing '93 5.8L



For the label specific to YOUR vehicle, click [url=http://www.motorcraftservice.c...
(Posted in: Diagrams)

02Cylinder.JPG
16355 hits | 45.41 KB | Posted: 1/28/06
To do any work inside the column: first, remove the lock cylinder by turning the key to RUN, then pressing the release button through the access hole in the lower shroud. Then pull the lock cylinder out.

Be careful not to accidentally turn the key ...
(Posted in: Steering Column)

TorqueConverter00.jpg
16346 hits | 63.97 KB | Posted: 5/7/05
Torque Converter Cutaway 4R70W

Torque Converter Operation Test

This test verifies that the torque converter clutch control system and the torque converter are operating correctly.
1. Carry out Quick Test with scan tool. For additional informat...
(Posted in: Diagrams)