Switch-SenderV8.JPG
16342 hits | 74.2 KB | Posted: 11/15/09
Oil Pressure Switch to Sender
IF THE IMAGE IS TOO SMALL, click it.

Swapping from a factory oil pressure switch to a factory-style sender causes the factory oil pressure gauge to actually work instead of behaving like an idiot light. Ford (and some ...
(Posted in: '87-96 Instruments, Low Fuel Light, Oil Pressure)

HeaterHose58L.JPG
16306 hits | 97.8 KB | Posted: 5/3/07
Heater Hose Routing for 5.8L


Reversing the heater core hoses ( 8 ) AT THE HEATER CORE will not cause any probl...
(Posted in: Diagrams)

Brake Line Components.jpg
16302 hits | 66.65 KB | Posted: 1/13/06
Brake Lines for RABS Trucks
IF THE IMAGE IS TOO SMALL, click it.

The two middle sections (showing the Union) & the bottom Right view apply to all '80-96 1/2-tons, EXCEPT the [url=https://www.amazon.com/dp/B001H1MQFI]ABS sensor (DY1123, F85Z-9E731-A...
(Posted in: Brakes & Hubs)

Dshafts&Ujoints.jpg
16275 hits | 52.83 KB | Posted: 1/25/06
Driveshafts & U-joints
IF THE IMAGE IS TOO SMALL, click it.

To check u-joints while the d'shaft is installed, set the e-brake, shift to N, and see how far you can rotate the t-case output back&forth WITHOUT moving the rear axle yoke/companion flange...
(Posted in: Diagrams)

NovParkFrtGrilel 50.JPG
16217 hits | 40.32 KB | Posted: 11/3/03
(Posted in: November evening.)

SenderOilPress.jpg
16172 hits | 33.27 KB | Posted: 1/15/06
Oil Pressure Sender (EOAZ-9278-A, SW-873B, PS60)

The NAPA number for the old-style oil pressure sender that is needed to convert a fake gauge into a real working one is OP6091. The BWD number is S334....
(Posted in: '87-96 Instruments, Low Fuel Light, Oil Pressure)

Distributor87-91.JPG
16125 hits | 72.95 KB | Posted: 10/30/10
Distributor '87-91, Open Bowl
Integral ICM, Push-Start (Gray)

The distributor-mounted TFI-IV Ignition Control Module (ICM) is known to suffer from overheating, and commonly fails. A special (but cheap) tool is required to change it, and the distrib...
(Posted in: Diagrams)

MaintSched92.JPG
16110 hits | 140.51 KB | Posted: 10/26/10
1992 Gasoline Light Truck Maintenance Schedule (essentially the same as all '88-96 F150s & Broncos, and some others)
IF THE IMAGE IS TOO SMALL, click it.
[url=http://www.fordservicecontent.com/Ford_Content/catalog/owner_guides/96bromg1e.pdf]'96 Bronc...
(Posted in: Diagrams)

BedBoltsPU.JPG
16054 hits | 63.35 KB | Posted: 1/4/07
Pickup Bed Bolts

Photos of a bed being removed can be found in this album:


For tailgate details, see this:
[url=h...
(Posted in: Diagrams)

Amateur_College_Girls_In_Thongs_Pic_01.jpg
16051 hits | 28.91 KB | Posted: 7/8/06
(Posted in: Hotties)

HubLockAuto95up.jpg
16044 hits | 71.88 KB | Posted: 1/2/06
3-screw Warn Automatic Hub Locks (F6TZ-1K105-AA)

Regarding part #3: I think the double-lip faces INboard (toward the diff) so that if pressure is higher OUTside the hub (deep water), the double-lip wil...
(Posted in: Brakes & Hubs)

8.8inch.jpg
15981 hits | 49.41 KB | Posted: 12/2/05
8.8" Axle Exploded, with open differential
Early versions have a ~2.87" hub flange stickout (pilot), causing the wheels to be lugcentric. Most have ~3.47" (~'87-96) and hubcentric wheels.

Axle Shaft (4234)
Left: E7TZ4234B, [url=https...
(Posted in: 8.8" Axle)

M5ODR2 exploded.JPG
15971 hits | 70.03 KB | Posted: 10/13/10
Mazda M5OD-R2 Exploded
IF THE IMAGE IS TOO SMALL, click it.

M5OD-R2 TRANSMISSION GEAR RATIOS (according to this page):
1 - 3.90 : 1
2 - 2.25 : 1
3 - 1.49 : 1
4 - 1.00 : 1
5 - 0.80 : 1
R - 3.39 : 1...
(Posted in: Diagrams)

thompsonhill.jpg
15848 hits | 28.42 KB | Posted: 6/29/03
Thompson Hill, a little too late the first day
(Posted in: Dusy Ershim 2002)

NP435.jpg
15783 hits | 97.44 KB | Posted: 5/22/07
Rebuilding the New Process 435
IF THE IMAGE IS TOO SMALL, click it.



IDENTIFICATION
Ford & Chrysler 4-speed manua...
(Posted in: NP-435 Swap)

Relays.JPG
15735 hits | 47.88 KB | Posted: 11/28/11
Starter Relays
The new style is a direct replacement for, AND a significant improvement on, the old one (E9TZ-11450-B).

See also:
[url=https://www.supermotors.net/registry/media/1036620][img]https://www.supermotors.net/getfile/1036620/thumbnail/sw19...
(Posted in: Diagrams)

RivetReplacement.jpg
15735 hits | 50.79 KB | Posted: 11/1/05
Rivet Replacement with Bolts
For other TSBs, check here.

TSB 97-4-7 FRAME - RIVET REPLACEMENT WITH BOLTS

Publication Date: FEBRUARY 17, 1997

LIGHT TRUCK:
1980-1996 BRONCO
1980-1997 ECONO...
(Posted in: TSBs & FSAs (Recalls) for '83-96 Broncos & F150s)

B4.JPG
15679 hits | 78.47 KB | Posted: 7/13/03
'80-96 rotor replacement requires removing the hub assembly & driving out the lug studs (Dorman 610-219). On '93-96 Broncos only, the tone ring must be removed.

'80-93 Front Rotor [url=https://www.ama...
(Posted in: Brakes & Hubs)

Right kick modules.JPG
15674 hits | 80.83 KB | Posted: 7/11/03
ERROR ! ! ! ! ! ! ! ! ! !

The module I MISlabelled as "Airbag" is actually the Wiper Control Module (WCM). The Airbag Diagnostic Module (ADM) is light blue, wrapped in black foam, above the gas pedal.
(Posted in: Base Album)

v9.JPG
15651 hits | 66.94 KB | Posted: 7/4/03
4th of july 2003
(Posted in: July2003)

Cruise Vacuum 92V8.jpg
15646 hits | 83.32 KB | Posted: 1/30/05
92 Cruise V8

See also:
. [url=http://www.supermotors.net/vehicles/registry/media/185339][img]ht...
(Posted in: Diagrams)

Dash92-96.JPG
15629 hits | 70.14 KB | Posted: 3/24/07
Dash Exploded '92-96
IF THE IMAGE IS TOO SMALL, click it.

This shows a DISASSEMBLED dash; to REMOVE the dash, this is NOT necessary. In fact, one of the screws near the center of the dash is installed inside the air ducts, making it impossible to a...
(Posted in: Diagrams)

Good Deeds 4 Victims & Heroes.jpg
15593 hits | 76.77 KB | Posted: 6/30/03
Good Deeds for Victims & Heroes
(Posted in: Cards)

Vacuum 86 F-150 EFI.JPG
15567 hits | 60.83 KB | Posted: 7/14/03
VECI label from '86 5.0L EFI



For the label specific to YOUR ~'90-up Ford, click [url=http://www.motorcraftser...
(Posted in: Diagrams)

Kids 004.jpg
15547 hits | 91.57 KB | Posted: 2/16/11
Keolas 2006 Ram 2500 Cummins Mega Cab. 12 inch lift on custom springs, 36x14.50s rollin heavy on 18x12s soon to be 38x15.50s on 20x14s. Welcome to Maui.....CHEEHU!
(Posted in: Misc. Family Pics)

RepairLocationsBronco.JPG
15501 hits | 77.65 KB | Posted: 1/13/07
'80-96 Bronco Repair Locations Grid & Coding
IF THE IMAGE IS TOO SMALL, click it.

More examples:

The transmission MLPS is at C5/FU.
The rear diff cover is at CD8/FU.
The air filter on EFI trucks is at A3/BU.
The passenger window motor is at F5/FO.
...
(Posted in: Diagrams)

Tires16.JPG
15357 hits | 60.76 KB | Posted: 6/26/09
It almost looks respectable now!


(Posted in: Vicky)

DSCF0046.JPG
15296 hits | 81.98 KB | Posted: 1/6/05
(Posted in: LANDYOT Radius Rod Installation)

BeltRouting.jpg
15224 hits | 68.67 KB | Posted: 1/25/06
Serpentine Belt Routing & Tensioner

Use a wrench on the tensioner pulley bolt (NOT the tensioner mounting bolt) or a square drive in the hole on the tensioner arm (if provided).

Measure belt tension using the special tool after retracting & then sl...
(Posted in: Diagrams)

FlangeHubLocks.jpg
15093 hits | 33.92 KB | Posted: 1/1/07
Flange-style manual hub locks used only on '87-early '88 F150s & Broncos w/manual locks. '87-88 w/auto locks are "normal".
IF THE IMAGE IS TOO SMALL, click it.

These are similar to those used on Bronco IIs & Explorers, but larger (5 on 5...
(Posted in: Brakes & Hubs)

RadiusArmBrktRplc.jpg
15080 hits | 75.44 KB | Posted: 1/1/07
TSB 91-21-08 (Excerpt)

For this full & other TSBs, check here.

Replacing the RIGHT side radius arm bracket fasteners on vehicles built prior to February 1990.
(This does not apply to F-350 4X4...
(Posted in: TSBs & FSAs (Recalls) for '83-96 Broncos & F150s)

Oil Temp Range.jpg
15078 hits | 50.34 KB | Posted: 10/30/05
TSB 02-1-9 ENGINE OIL - RECOMMENDED APPLICATIONS FOR SAE 5W-20 AND SAE 5W-30 MOTOR OILS - GASOLINE AND FLEXIBLE FUEL VEHICLES ONLY
Publication Date: JANUARY 14, 2002

FORD:
1992-2002 CROWN VICTORIA
1993-1994 TEMPO
1993-1997 THUNDERBIRD
1993-2002...
(Posted in: TSBs & FSAs (Recalls) for '83-96 Broncos & F150s)

prox600_3.JPG
14999 hits | 76.52 KB | Posted: 3/3/05
(Posted in: Sled Showroom)

351M exploded.jpg
14848 hits | 67.88 KB | Posted: 7/14/03
351M Exploded
(Posted in: Diagrams)

Cluster&Bezel92-96.jpg
14845 hits | 95.19 KB | Posted: 10/8/09
Instrument Cluster & Bezel '92-96 (& '97 over 8500GVWR)
IF THE IMAGE IS TOO SMALL, click it.

Be EXTREMELY careful unplugging the devices screwed to the back of the cluster bezel (ESOF switches, Bronco rear window switch, F-series tank switch or jump...
(Posted in: Diagrams)

D60 Front.jpg
14836 hits | 64.02 KB | Posted: 7/14/03
Dana 60 Front Exploded

See also:
What's the DIFF?
Dana Axle Expert
(Posted in: Diagrams)

StarterRelay93conns.JPG
14784 hits | 64.93 KB | Posted: 10/8/10
Starter Relay (E9TZ-11450-B) Connections '92-96
IF THE IMAGE IS TOO SMALL, click it.

The relay trigger wire (R/LB) comes from the ignition switch via the clutch switch or MLPS and should only be hot with the key in START and either the clutch fully ...
(Posted in: General Purpose Pics)

StarterWiringOld.JPG
14780 hits | 81.36 KB | Posted: 8/25/11
Early Starter Wiring ('87-91 similar)
IF THE IMAGE IS TOO SMALL, click it.

10655 - Battery (Group 65)
11002 - Starter motor
11450 - Starter relay (E9TZ-11450-B)
12581 - Wiring harness, starter relay to alternator & fuse block
14300 - Cable, battery ...
(Posted in: Diagrams)

TSB87-16-15ClutchPedalLow.jpg
14741 hits | 55.12 KB | Posted: 4/20/09
TSB 87-16-15 Clutch Pedal Low

LIGHT TRUCK: 1984-87 F-150/350, BRONCO (also applies to '88-96 & '97 >8500GVWR)

ISSUE: A clutch pedal not fully returning to contact the rubber bumper at the "up" stop may result in any of the following condi...
(Posted in: TSBs & FSAs (Recalls) for '83-96 Broncos & F150s)

DSCF0011.JPG
14723 hits | 65.52 KB | Posted: 1/6/05
(Posted in: LANDYOT Radius Rod Installation)

C6Exploded.jpg
14665 hits | 45.36 KB | Posted: 2/17/07
C6 Exploded & Hydraulic Schematic
IF THE IMAGE IS TOO SMALL, click it.

1 7902 Torque Converter
2 87650-S Converter Drain Plug, 1/8-27, Dryseal Tapered Thread
3 7017 Input Shaft
4 Front Pump Seal (Part of 7A103)
5 Front Pump Bushing (Part ...
(Posted in: Diagrams)

03CylRem.JPG
14642 hits | 45.28 KB | Posted: 1/28/06
This is what the probe pressed in to release the cylinder. When the key is rotated, the pin will be forced back out. The key must be in RUN and the pin pushed in before the cylinder can be re-installed. Some later cylinders have a rounded spring-l...
(Posted in: Steering Column)

11WireOut.jpg
14634 hits | 66.25 KB | Posted: 1/28/06
Remove the wire from its guides & retainers so it's free all the way to the base of the shift lever.
(Posted in: Steering Column)

T-Case93ES.jpg
14632 hits | 32.72 KB | Posted: 1/22/05
93 Bronco Transfer Case (BW1356) Electronic Shift-On-the-Fly (ESOF) (F1TA-7A195-DA)
IF THE IMAGE IS TOO SMALL, click it.

[url=http://www.supermotors.net/vehicles/registry/media/469461][img]http://www.supermotors.net/getfile/469461/thumbnail/bw1356es...
(Posted in: Diagrams)

4R70WDisassembled98.jpg
14520 hits | 73.52 KB | Posted: 4/3/05
Exploded 4R70W
1 7902 Converter Assy
2 87650-S2 Plug - Converter Drain - 1/8-27 Dryseal
3 7A103 Pump Assy - Front
4 7A248 Seal Assy - Front Pump
5 7A248 Seal - Front Pump
6 7B258 Bushing - Front Pump
7 N605789-S100Bolt - M8-1.25...
(Posted in: Diagrams)