|
|
Hits: 592
Size: 110.88 KB
Posted: 5/17/05
We had a couple times the van did not want to start and the charging system seemed low. i found the ... | 
Hits: 520
Size: 110.3 KB
Posted: 5/17/05
this is where the Aux power line goes to and i decided to pull the tray and clean it. then paint it. | 
Hits: 504
Size: 70.73 KB
Posted: 5/17/05
this is another pic of the battery tray in the van. it is all surface at this time. | 
Hits: 559
Size: 113.95 KB
Posted: 5/17/05
here it is out of the van----that was a pain-someone ran the e-brake cable thu the mount so i had to... | 
Hits: 559
Size: 125.57 KB
Posted: 5/17/05
2 coats primer and a couple coats of flat black it looks new again. |
Hits: 561
Size: 108.7 KB
Posted: 5/17/05
here is the old pos bandaided cable 6' long. | 
Hits: 525
Size: 147.13 KB
Posted: 5/17/05
here is another shot of the bandaid---the AUX wire is not showing but i replaced it too. | 
Hits: 531
Size: 148.18 KB
Posted: 5/17/05
While i was there i got a new Neg cable too.This is the old one. | 
Hits: 523
Size: 111.15 KB
Posted: 5/17/05
Here is the new cables along with the old neg. i had a set made out of 2 guage welding wire. these w... | 
Hits: 545
Size: 113.08 KB
Posted: 5/17/05
this is the new cables in and the new AUX power take off. Much better |
Hits: 552
Size: 90.81 KB
Posted: 5/17/05
the neg is 2 pieces i replaced the 1st leg as the rest looked ok for now. it goes from the battery t... | 
Hits: 557
Size: 79.49 KB
Posted: 7/14/05
The windows went up and down real slow and not at all sometimes. i found a couple versions on ebay i... | 
Hits: 538
Size: 91.36 KB
Posted: 7/14/05
here is the side shot | 
Hits: 624
Size: 93.28 KB
Posted: 7/14/05
the other side. i was able to swap these out in 15 each side. 4 rivets hold the old in and i greased... | 
Hits: 2497
Size: 84.18 KB
Posted: 7/5/06
Here is a 3.8 tarus 2 speed fan. $19 at the local junk yard. these have a high and low speed and rea... |
Hits: 1210
Size: 80.19 KB
Posted: 7/5/06
here is the back side of the fan. it came complete as seen in the picture. | 
Hits: 1181
Size: 82.2 KB
Posted: 7/5/06
Hereis a continus duty relay. it can handle 80 amps all the time. the fan spikes @ 100 amps at start... | 
Hits: 1130
Size: 85.73 KB
Posted: 7/5/06
I wanted to get some of the wires off the battery. so i picked up a single point power take off. Thi... | 
Hits: 690
Size: 44.85 KB
Posted: 7/5/06
on the inside i needed to get an ignition on power source. so i taped one of the acc on ports in the... | 
Hits: 1991
Size: 73.57 KB
Posted: 7/5/06
Here is the fan temp power controler. I got it new from Autozone $24. the ignition on wire goes to t... |
Hits: 665
Size: 87.34 KB
Posted: 8/23/06
here is another rear window latch. they do not last too long. | 
Hits: 755
Size: 85.58 KB
Posted: 8/23/06
while replacing the radaitor i installed a new NAPA water pump. | 
Hits: 686
Size: 74.96 KB
Posted: 8/23/06
here is the other side of the box. | | |
1992 GMS Safari