michael collins > 1983 Ford Bronco > open folder 1992 GMS Safari

We had a couple times the van did not want to start and the charging system seemed low. i found the ...
Url
Tag
Img
Thumb
this is where the Aux power line goes to and i decided to pull the tray and clean it. then paint it.
Url
Tag
Img
Thumb
this is another pic of the battery tray in the van. it is all surface at this time.
Url
Tag
Img
Thumb
here it is out of the van----that was a pain-someone ran the e-brake cable thu the mount so i had to...
Url
Tag
Img
Thumb
2 coats primer and a couple coats of flat black it looks new again.
Url
Tag
Img
Thumb
here is the old pos bandaided cable 6' long.
Url
Tag
Img
Thumb
here is another shot of the bandaid---the AUX wire is not showing but i replaced it too.
Url
Tag
Img
Thumb
While i was there i got a new Neg cable too.This is the old one.
Url
Tag
Img
Thumb
Here is the new cables along with the old neg. i had a set made out of 2 guage welding wire. these w...
Url
Tag
Img
Thumb
this is the new cables in and the new AUX power take off. Much better
Url
Tag
Img
Thumb
the neg is 2 pieces i replaced the 1st leg as the rest looked ok for now. it goes from the battery t...
Url
Tag
Img
Thumb
The windows went up and down real slow and not at all sometimes. i found a couple versions on ebay i...
Url
Tag
Img
Thumb
here is the side shot
Url
Tag
Img
Thumb
the other side. i was able to swap these out in 15 each side. 4 rivets hold the old in and i greased...
Url
Tag
Img
Thumb
Here is a 3.8 tarus 2 speed fan. $19 at the local junk yard. these have a high and low speed and rea...
Url
Tag
Img
Thumb
here is the back side of the fan. it came complete as seen in the picture.
Url
Tag
Img
Thumb
Hereis a continus duty relay. it can handle 80 amps all the time. the fan spikes @ 100 amps at start...
Url
Tag
Img
Thumb
I wanted to get some of the wires off the battery. so i picked up a single point power take off. Thi...
Url
Tag
Img
Thumb
on the inside i needed to get an ignition on power source. so i taped one of the acc on ports in the...
Url
Tag
Img
Thumb
Here is the fan temp power controler. I got it new from Autozone $24. the ignition on wire goes to t...
Url
Tag
Img
Thumb
here is another rear window latch. they do not last too long.
Url
Tag
Img
Thumb
while replacing the radaitor i installed a new NAPA water pump.
Url
Tag
Img
Thumb
here is the other side of the box.
Url
Tag
Img
Thumb
  
About SuperMotors | Contact Us | FAQ/Help | Legal
Copyright © 1998-2022 Web Design Solutions, Inc.
All rights reserved. Duplication & reproduction is strictly prohibited.
SuperMotors.net v5.0.2 ChangeLog