michael collins > 1983 Ford Bronco > open folder Aqua Magic Swap

This is a Thetford Aqua Magic Potty. it provided many good years of service. it sprung a leak while ...
Url
Tag
Img
Thumb
This is the printed sticker under the top lid.
Url
Tag
Img
Thumb
Here is the working end of the potty. There is 3 13mm nuts holding the potty to the floor. i removed...
Url
Tag
Img
Thumb
after disconnecting the water supply and the 2 nuts the potty comes right off.
Url
Tag
Img
Thumb
This is the #1 failure part. they are readily avalable at most camping worlds or RV pats houses.
Url
Tag
Img
Thumb
if you have small hands you can swap the part without disassembly of the whole potty. here is the ba...
Url
Tag
Img
Thumb
After removing the screws the lower half comes right up. i had to disconnect 2 hoses and the base is...
Url
Tag
Img
Thumb
this is the supply valve. you can see 2 screws hold it in place. this is a common falure part. I bou...
Url
Tag
Img
Thumb
The view was just for me. i wanted to have a view of how the springs were connected so if they came ...
Url
Tag
Img
Thumb
this is the old valve and supply line.
Url
Tag
Img
Thumb
This is the new rebuild kit. all the parts are in one bag. you can see the part number 09868 on the ...
Url
Tag
Img
Thumb
here is a closer shot of the part number
Url
Tag
Img
Thumb
Here is the old and new supply valves.
Url
Tag
Img
Thumb
here is the supply valve installed. if you undid the supply line and removed the nut and 2 screws yo...
Url
Tag
Img
Thumb
I found a 2nd leake the vacuum break. it is in the tank in this shot. bad news was 2 weeks to get on...
Url
Tag
Img
Thumb
My bad news was my potty mount was for only one mounting and not going to work with the new potty. t...
Url
Tag
Img
Thumb
I took my dramil and cut the flange top ring.
Url
Tag
Img
Thumb
here is the new flange installed. it was called an inside slider flange and purchased from Home Depo...
Url
Tag
Img
Thumb
Here is the bottom of the new potty. I instaled the new bottom gasket.
Url
Tag
Img
Thumb
I had to extend the water supply line 6" for the new potty. i got the parts from Home Depot and Lowe...
Url
Tag
Img
Thumb
Here it i all installed and ready for use.
Url
Tag
Img
Thumb
Here is the side front view. looks almost like the old one but no foot pedals
Url
Tag
Img
Thumb
Here is the working half and it is ready for work.
Url
Tag
Img
Thumb
Here is the stamped label under the top lid.
Url
Tag
Img
Thumb
Allnew pottys come with a spray wand. i just installed the mount on the wall and put the wand in the...
Url
Tag
Img
Thumb

About SuperMotors | Contact Us | FAQ/Help | Legal
Copyright © 1998-2022 Web Design Solutions, Inc.
All rights reserved. Duplication & reproduction is strictly prohibited.
SuperMotors.net v5.0.2 ChangeLog