BodyMountHdwr.JPG
4413 hits | 75.25 KB | Posted: 6/27/08
SOLD Body Mount Hardware from '96 Bronco 7/16"-14tpi

Does not include core support parts, which are even harder to find & remove intact than these.

See also:
[url=http://www.supermotors.net/registry/media/72356][img]http://www.supermotors.net/...
(Posted in: Body Mounts)

BodyMtBolts.jpg
516 hits | 60.57 KB | Posted: 11/7/21
Bronco Body Mount Bolts
IF THE IMAGE IS TOO SMALL, click it.

The front bolts are M12x1.75 100mm FULLY THREADED w/15mm head & small integral washer.
The 6 identical bolts are 7/16"x14(NC) 3.75" long threaded 2.5" with a 5/8" head ...
(Posted in: Body Mounts)

PSGearBox.JPG
38346 hits | 91.8 KB | Posted: 5/7/07
Ford Integral Power Steering Gear Box

See also:
. [url=http://www.supermotors.net/registry/2742/77493-4][img]h...
(Posted in: Diagrams)

JackPoints86Fr.JPG
8747 hits | 85.27 KB | Posted: 10/13/10
Front Jacking Points for '86 F-series & Bronco

'80-96 similar


(Posted in: Diagrams)

SteeringBoxExploded.JPG
7342 hits | 86.92 KB | Posted: 11/9/11
Steering Box

See also:
. [url=http://www.supermotors.net/registry/media/997641][img]http://www.supermotors.net/g...
(Posted in: Diagrams)

FuelLines9096.jpg
901 hits | 143.13 KB | Posted: 9/3/14
Fuel Lines for '92-96 Broncos

SOLD tank-to-filter section

See also:

(Posted in: Spare Parts)

FuelLine9549.jpg
264 hits | 83.17 KB | Posted: 1/21/22
Fuel Lines (engine section only) from a '95 4.9L
IF THE IMAGE IS TOO SMALL, click it.

See also:

(Posted in: Spare Parts)

FuelLine96B58.jpg
245 hits | 59.63 KB | Posted: 1/21/22
Complete Fuel Line Set from '96 5.8L Bronco
IF THE IMAGE IS TOO SMALL, click it.

See also:

(Posted in: Spare Parts)

VisorsDualPairs.jpg
339 hits | 64.01 KB | Posted: 1/21/22
'94-96 Mocha Double Visor Sets
IF THE IMAGE IS TOO SMALL, click it.

These are the working sets I have as of the image upload date. The #1 set looks the best to me, but not by much; #3 would be best if it didn't have that black mark. I also have one ...
(Posted in: Spare Parts)

Center Bent.JPG
9399 hits | 29.6 KB | Posted: 11/28/04
This is why the inside handle doesn't sit flat. If someone pulls the handle before the glass is fully down (disengaging the interlock), then the handle lever bends.

[url=https://www.supermotors.net/registry/media/1164065][img]https://www.supermotor...
(Posted in: Tailgate Tech)

Center Straight.JPG
8507 hits | 25.77 KB | Posted: 11/28/04
Fortunately, with the mechanism out, it's easy to straighten the bent lever. Spray it with WD-40 or flowable grease before re-installing it. If the center (top) lever doesn't rotate freely enough for the coil spring to return it, the latches can't ...
(Posted in: Tailgate Tech)

RemBent.JPG
3049 hits | 118.03 KB | Posted: 4/21/14
I've never found a used tailgate whose remote was NOT bent, but this is among the worst.


(Posted in: Tailgate Tech)

RABS-II Circuit.jpg
7367 hits | 60.91 KB | Posted: 1/13/06
RABS & RABS-II Circuit
IF THE IMAGE IS TOO SMALL, click it.

The ABS sensor (DY1123, F85Z-9E731-AB) in the rear diff should read 800-1400 Ohms across the pins, and more than 10 Ohms from the metal shel...
(Posted in: Brakes & Hubs)

M5ODR2 exploded.JPG
18039 hits | 70.03 KB | Posted: 10/13/10
Mazda M5OD-R2 Exploded
IF THE IMAGE IS TOO SMALL, click it.

M5OD-R2 TRANSMISSION GEAR RATIOS (according to this page):
1 - 3.90 : 1
2 - 2.25 : 1
3 - 1.49 : 1
4 - 1.00 : 1
5 - 0.80 : 1
R - 3.39 : 1...
(Posted in: Diagrams)

M5ODR2Ex.JPG
22031 hits | 93.15 KB | Posted: 11/8/11
Mazda M5OD-R2 Disassembly
IF THE IMAGE IS TOO SMALL, click it.

M5OD-R2 TRANSMISSION GEAR RATIOS:
1 - 3.90 : 1
2 - 2.25 : 1
3 - 1.50 : 1
4 - 1.00 : 1
5 - 0.80 : 1
R - 3.39 : 1

First Gear
The first/second synchronizer is splined to the output shaft. ...
(Posted in: Diagrams)

ShifterBoltMazda.jpg
1018 hits | 39.96 KB | Posted: 5/12/22
Mazda M5OD (and possibly others) Shifter Wedge Bolt (7L197)

The nut is normally installed on the LOCK side to hold the shifter tight. To extract the wedge, tighten the nut on the REMOVE side until it slides out, then pull the shifter handle off th...
(Posted in: General Purpose Pics)

PumpHPearly.JPG
4346 hits | 57.6 KB | Posted: 11/6/11
Early High-Pressure Fuel Pump & Filter
IF THE IMAGE IS TOO SMALL, click it.


(Posted in: '84-89 Fuel Reservoirs)

FuelSystemEarly.jpg
2464 hits | 72.37 KB | Posted: 5/12/22
'85-89 Fuel Systems
IF THE IMAGE IS TOO SMALL, click it.

For Type 2 SFR, read this page & the NEXT several:

[url=https://www.supermotors.net/registry/media/669585_1][img]https://www.supermotors.net/getfile/669585/thumbnail/singlefunctionreserv...
(Posted in: '84-89 Fuel Reservoirs)

BoltSeized.jpg
299 hits | 90.08 KB | Posted: 5/16/22
Seized Seat Belt Bolt in a '95 F150 XLT
IF THE IMAGE IS TOO SMALL, click it.

After breaking 2 impact-rated T50 bits, I realized this bolt needed more encouragement. So I hammered on this spiral extractor, and it finally broke loose.
(Posted in: Seats & Belts)

BoltXtract.jpg
285 hits | 88.64 KB | Posted: 5/16/22
Seized Seat Belt Bolt in a '95 F150 XLT
IF THE IMAGE IS TOO SMALL, click it.

The lip of the head is easier to apply torque to than the Torx recess in the center, which was rusty & began to strip. But the head sheared off the bolt, so the remainde...
(Posted in: Seats & Belts)

SparkPlugDiag.jpg
14149 hits | 60.58 KB | Posted: 10/12/10
Spark Plug DIagnosis
IF THE IMAGE IS TOO SMALL, click it.
The inside back cover of any Haynes manual is much better than this B&W diagram.

[url=https://www.supermotors.net/registry/media/449785][img]https://www.supermotors.net/getfile/449785/thumbna...
(Posted in: Diagrams)

RVmirButton.jpg
307 hits | 50.94 KB | Posted: 5/18/22
Screwless Rear-View Mirror
IF THE IMAGE IS TOO SMALL, click it.

A tool was made to release the mirror's catch from the glass button, but it's not necessary. Simply insert a common pocket screwdriver into the offcenter notch in the bottom of the ...
(Posted in: Overhead Console & Dual Visors)

OH Console & Mirror.JPG
6493 hits | 95.65 KB | Posted: 7/10/03
If you're looking for a Bronco overhead console, e-mail me thru my profile here or on almost any BBS dealing with Ford trucks or Crown Vics. I usually have a few.

For calibration, see this:
[url=https://www.supermotors.net/registry/media/161990][img...
(Posted in: Overhead Console & Dual Visors)

Harness96Dash..JPG
12137 hits | 77.8 KB | Posted: 8/8/07
STRIPPED Dash Harness from a '96 F150
IF THE IMAGE IS TOO SMALL, click it.

C216 is an unused carryover connector from the older vacuum cruise amplifier, which was not used in these trucks after 1992. I have not found any explanation why it exists in...
(Posted in: General Purpose Pics)

50LExploded.jpg
31193 hits | 113.08 KB | Posted: 4/10/08
5.0L Exploded
IF THE IMAGE IS TOO SMALL, click it.
Automotive Terms & Abbreviations

Bore x Stroke: 4.00 x 3.00
Oil Pressure @ 190°F 2KRPM: 275-413kPa (40-60psi)
[url=https://www.s...
(Posted in: Diagrams)

FanCircuit.JPG
8399 hits | 32.5 KB | Posted: 10/21/07
2-Speed Cooling Fan Circuit only allows the fans to run when the engine is running (because it's powered by the fuel pump relay), but gives the driver control (OFF) for water crossings or (ON) in case the temperature switches fail.

In this configura...
(Posted in: Diagrams)

FanCircuitA.JPG
9523 hits | 25.72 KB | Posted: 6/6/08
Single-Speed Cooling Fan Circuit only allows the fans to run when the engine is running (because it's powered by the fuel pump relay), but gives the driver control (OFF) for water crossings or (ON) in case the temperature switch fails.

For a stock t...
(Posted in: Diagrams)

FanCircuitB.JPG
3678 hits | 32.76 KB | Posted: 11/1/11
2-Speed Cooling Fan Motor Circuit only allows the fan to run when the engine is running (because it's powered by the fuel pump relay), but gives the driver control (OFF) for water crossings or (ON) in case the temperature switches fail. In this conf...
(Posted in: Diagrams)

FanCircuitC.JPG
2927 hits | 38.65 KB | Posted: 4/29/13
A more-complex variation of the 2-speed e-fan circuit; this one includes a relay that allows high speed when the A/C is running. Note that the OFF position on the dash switch does not affect the high-speed relay, so it's idiot-proof. Even if the da...
(Posted in: Diagrams)

FanCircuitBi.jpg
1723 hits | 35.68 KB | Posted: 10/26/16
2-Speed Cooling Fan Motor Circuit (with illuminated switch) only allows the fan to run when the engine is running (because it's powered by the fuel pump relay), but gives the driver control (OFF) for water crossings or (ON) in case the temperature sw...
(Posted in: Diagrams)

DashPadBlue.JPG
1616 hits | 68.46 KB | Posted: 9/18/09
SOLD '92-93 Crystal Blue Dash Pad

'94-97 Lapis Blue is brighter



Blemish-free with 7 original nuts.

Ship...
(Posted in: SOLD)

OHCS2LLB.JPG
1391 hits | 84.04 KB | Posted: 3/20/12
SOLD Bronco Overhead Console Set (Complete)
IF THE IMAGE IS TOO SMALL, click it.

Includes A-pillar wiring harness & the pigtail to splice into the dash harness, temperature sensor & pigtail, all original fasteners, original rear-view mirror, garage ...
(Posted in: SOLD)

Console95bu.JPG
1200 hits | 68.9 KB | Posted: 5/18/12
SOLD Blue '94-96 Floor Console (F2TZ18045A36C)
(Posted in: SOLD)

Column95Fa.jpg
206 hits | 55.54 KB | Posted: 2/1/22
SOLD '95 F150 XLT Manual Trans Steering Column (without wheel or clock spring)
IF THE IMAGE IS TOO SMALL, click it.
(Posted in: SOLD)

TGT-Rod.JPG
4554 hits | 82.16 KB | Posted: 6/11/07
Tailgate Torsion Bar (F4TZ9844890A) from '95 Bronco fits all '78-96 Bronco tailgates.
IF THE IMAGE IS TOO SMALL, click it.
Actual size: 59x15x2" 2.6 lbs

See this pic for associated hardware:
http://www.supermotors.net/vehicles/registry/media/51...
(Posted in: Spare Parts)

TGRegulator.JPG
9504 hits | 60.58 KB | Posted: 5/17/07
'78-96 Bronco Tailgate Window Regulator front & back
(early regulator arms may have round swivels instead of square)
Motor wires are 35", with a retainer 12" from the motor, a molded rubber 90° bend at 20", another retainer 1/2" p...
(Posted in: Tailgate Tech)

4WABS93.JPG
712 hits | 85.6 KB | Posted: 5/29/22
4WABS Circuit & Connectors
IF THE IMAGE IS TOO SMALL, click it.

'93 Bronco shown; '94-96 Bronco similar.
Front Wheel Speed Sensor Motorcraft BRAB30; Airtex ; Dorman 970-020; Standard ALS185; Motone...
(Posted in: Brakes & Hubs)

TaillightHrns83B2.jpg
289 hits | 62.67 KB | Posted: 5/30/22
Taillight Harness from '83 Bronco
IF THE IMAGE IS TOO SMALL, click it.

I'm not sure which side this is, or if they're identical.
(Posted in: Spare Parts)

TaillightHarness93B.jpg
308 hits | 77.24 KB | Posted: 5/30/22
Taillight Harness from '93 Bronco
IF THE IMAGE IS TOO SMALL, click it.

Same for L&R; probably fits '87-96 Broncos. I have 5 spares in '22.
(Posted in: Spare Parts)

WS_Tool9.jpg
6643 hits | 48.52 KB | Posted: 5/12/07
The lower trim clips are different, but they're released the same way.

These clips are intermittently not available new, so care should be taken not to damage them, or to allow them to corrode from debris trapped in the lower trim.

I have a few spa...
(Posted in: General Purpose Pics)

WS_Tool7.jpg
6281 hits | 45.25 KB | Posted: 5/12/07
The lower trim clips are different, but they're released the same way.

These clips are intermittently not available new, so care should be taken not to damage them, or to allow them to corrode from debris trapped in the lower trim.

I have a few spa...
(Posted in: General Purpose Pics)

ShifterPositionM5OD.jpg
327 hits | 69.68 KB | Posted: 6/3/22
Mazda M5OD-R2 Shifter Position
IF THE IMAGE IS TOO SMALL, click it.
(Posted in: General Purpose Pics)

RFIcap.jpg
1071 hits | 80.3 KB | Posted: 1/16/22
'87-95 RFI Capacitor Installation
IF THE IMAGE IS TOO SMALL, click it.


(Posted in: Diagrams)

ShopStump13.jpg
260 hits | 109.48 KB | Posted: 2/3/19
Even though the winch is at full-stall, it doesn't even look like there's any tension on it. It's not leaning, and the ground behind it isn't lifting at all.
(Posted in: Stress Testing)

Injectors19lb4hole.jpg
215 hits | 59.36 KB | Posted: 2/4/22
19 lb/hr 4-Hole Fuel Injectors (set of 8 )
IF THE IMAGE IS TOO SMALL, click it.
(Posted in: Spare Parts)