MMseat1.JPG
4081 hits | 25.69 KB | Posted: 3/1/07
http://www.crownvic.net/drock96marquis/seats.htm

Marauder Seat
(Posted in: TECH/MISC -- Click for MISC tech pics-SEE SUBS)

Cat.JPG
4089 hits | 74.6 KB | Posted: 7/17/09
Vicky has been VERY sluggish & noisy for about a year now, so I finally pulled the trigger on a new cat. I could hear huffing & rattling under my floorboard, so I knew the L side was the main problem. Ford gets ~$950 for this ($800 buddy-price), so...
(Posted in: Vicky)

Image078.jpg
4099 hits | 52.38 KB | Posted: 7/16/06
Sorry for the low quality cell phone pic-

Basically, is just an air-compressor water/air seperator with 1/4" NPT 3/8 hose barbs atached inline of the factory PCV.

Material I used:
~2ft fuel/oil 3/8" hose
1 1/4" NPT air-compressor inline water...
(Posted in: PCV system oil catch (7/'06))

HPIM0172.JPG
4102 hits | 46.25 KB | Posted: 10/22/06
Done, the original version

Pass side
(Posted in: Center Console & Floor Shifter Conversion (9/'05))

94-cv-frame[1].jpg
4106 hits | 74.93 KB | Posted: 8/6/09
1994 Vic frame diagram
(Posted in: Frame)

AIR95-98.jpg
4115 hits | 37.95 KB | Posted: 4/3/05
The Secondary Air Injection (AIR) System Monitor is an on-board strategy designed to monitor the proper function of the secondary air injection system. The AIR Monitor for the Belt-Driven Secondary Air Injection Pump system consists of two Output Sta...
(Posted in: Diagrams)

KSP 2006 P71.JPG
4128 hits | 45.59 KB | Posted: 8/28/06
Kentucky State Police
(Posted in: State Fair 2006)

Engine.JPG
4128 hits | 50.52 KB | Posted: 6/30/03
Engine bay (center pic)
(Posted in: Engine)

Interior 3-06.JPG
4140 hits | 64.47 KB | Posted: 3/19/06
Note the A-pillar gauge pod.
(Posted in: March 2006 Interior & Engine Pics)

HPIM0184.JPG
4150 hits | 64.45 KB | Posted: 10/22/06
The stock shifter cable, rerouted and floating on the new shifter.

I used a ton of nylon locking 'zip' ties to secure it down.

The shifter is bolted down using carriage bolts, and sealed with RTV.


In retrospect, some socket head cap bolts...
(Posted in: Center Console & Floor Shifter Conversion (9/'05))

020.JPG
4152 hits | 71.86 KB | Posted: 5/29/09
2004 Ford Crown Victoria LX Sport-Carbon Fiber Dashboard trim
(Posted in: 2004 Crown Victoria Lx Sport)

PDRM0297.JPG
4157 hits | 45.6 KB | Posted: 10/22/06
Even Later:

Mercury Marauder gauge pod replaces filler piece.
More pcitures here:
http://www.supermotors.net/vehicles/registry/7603/52261

Another
(Posted in: Center Console & Floor Shifter Conversion (9/'05))

Biscayne.JPG
4163 hits | 76.47 KB | Posted: 4/17/05
1965 Chevy Biscayne. Past fire cheif car, and will be restored back as a fire chief car.
(Posted in: Mustang Collection)

RASspringcollasped.JPG
4170 hits | 24.97 KB | Posted: 3/1/07
http://www.crownvic.net/drock96marquis/RAS.htm


-97 Panther RAS base-rate Airspring collapsed/operating position
(Posted in: TECH/MISC -- Click for MISC tech pics-SEE SUBS)

Exhaust.jpg
4184 hits | 31.32 KB | Posted: 8/11/05
1. Three Way Catalytic Converter, RH
2. Exhaust Damper, RH
3. Exhaust Inlet Pipe
4. Muffler, RH
5. Muffler, LH
6. Exhaust Damper, LH
7. Three Way Catalytic Converter, LH
(Posted in: Tech)

03-05transpowersteercooler.JPG
4184 hits | 84.26 KB | Posted: 7/24/08
(Posted in: TECH/MISC -- Click for MISC tech pics-SEE SUBS)

92through2005digicluster pinouts.JPG
4205 hits | 31.22 KB | Posted: 9/30/07
1992-2005 CV/GM DIGITAL cluster pinouts
(Posted in: Panther Instrument Cluster Schematics and Pinouts)

PDRM0146.JPG
4209 hits | 38.59 KB | Posted: 10/22/06
What I started out with.

A black, dirty console


Follwoing lots of cleaning, I painted it to match the factory Willow Green using custom mixed PPG Interior paint.
(Posted in: Center Console & Floor Shifter Conversion (9/'05))

CFI Parts 004.jpg
4213 hits | 55.2 KB | Posted: 6/27/05
(Posted in: CFI parts)

sta72121b.jpg
4221 hits | 77.94 KB | Posted: 12/21/08
Most recent interior shot. Note the EATC conversion!
(Posted in: Center Console & Floor Shifter Conversion (9/'05))

Fuse1994.jpg
4225 hits | 64.96 KB | Posted: 2/6/05
1994 Crown Victoria & Grand Marquis Fuses
(Posted in: Diagrams)

Headliner2.JPG
4227 hits | 66.42 KB | Posted: 12/6/06
Next, rotate the headliner's LHR corner (at the bottom near the driver's door) up along the L side of the car & work the LHF corner through the R footwell and across the trans tunnel. Keep the R edge of the headliner high in the door opening.
(Posted in: Headliner "Repair")

Self-Test.jpg
4242 hits | 23 KB | Posted: 12/4/04
Self-Test Jumper for EEC-IV

For more info, see this & the link in its caption:

(Posted in: Diagrams)

Plastigage.jpg
4244 hits | 50.95 KB | Posted: 1/2/05
Plastigage
(Posted in: Diagrams)

Driveshafts.JPG
4244 hits | 43.84 KB | Posted: 2/14/05
The upper steel driveshaft is slightly longer than the aluminum one, but the aluminum's yoke makes it longer overall.
(Posted in: 2000 Engine Installation)

Bondurant Vic.mov
4249 hits | 8.77 MB | Posted: 12/19/04
Manual Crown Victoria drifting at the Bondurant Driving School.
(Posted in: Bondurant Driving School)

Piston Ring Measurement.jpg
4249 hits | 52.25 KB | Posted: 1/2/05
3. Subtract piston diameter measurement from cylinder bore diameter measurement. Standard piston to bore clearance is 0.20-0.046mm (0.0008-0.0018 inch).
Service limit: 0.070mm MAX (0.0028 inch MAX)

NOTE: The actual piston diameter is indicated o...
(Posted in: Diagrams)

Main Bearing Diagnosis.jpg
4250 hits | 68.53 KB | Posted: 1/2/05
Main Bearing Diagnosis
(Posted in: Diagrams)

Water Pump R&R.jpg
4254 hits | 50.04 KB | Posted: 1/2/05
The pulley bolts are tightened the same as the WP bolts.
(Posted in: Diagrams)

RearSuspExploded.jpg
4255 hits | 70.57 KB | Posted: 1/16/05
Exploded 8.8" Suspension
(Posted in: Diagrams)

Head Gaskets.jpg
4280 hits | 32.09 KB | Posted: 1/2/05
NOTE: Clean cylinder head gasket surface with a toluene-based paint thinner or gasket remover. If gasket material remains on head after cleaning, use a 600 grit sandpaper to remove remaining material.

CAUTION: Do not use sandpaper coarser (lower n...
(Posted in: Diagrams)

SeatsPower.jpg
4281 hits | 74.29 KB | Posted: 1/18/06
Power Seats
IF THE IMAGE IS TOO SMALL, click it.


(Posted in: Seats & Belts)

engine bay front.JPG
4298 hits | 84.63 KB | Posted: 8/27/05
(Posted in: 2006 CVPI)

Truck 1-Small.jpg
4316 hits | 60.29 KB | Posted: 3/27/09
Mini
(Posted in: Mini Trucks)

MMshifter1.JPG
4324 hits | 15.77 KB | Posted: 3/1/07
For Comparison:
03-04 Mercury Marauder Shifter

Same as 01up LX Sport/LSE, but with dot matrix style trim and no chrome


Notice, the shifter is virtually the same as the Continental shifter but ~1/2" shorter. The most noticeable difference is that ...
(Posted in: Center Console & Floor Shifter Conversion (9/'05))

Cluster 98 P71.JPG
4351 hits | 59.37 KB | Posted: 2/9/05
SOLD Some blemishes on the lens are not visible in this photo, but they should come off with normal cleaning.
(Posted in: SOLD)

height sensor.JPG
4352 hits | 24.48 KB | Posted: 1/11/06
http://www.crownvic.net/drock96marquis/RAS.htm

-97 Panther RAS height sensor
(Posted in: TECH/MISC -- Click for MISC tech pics-SEE SUBS)

99wheelsensorconn.JPG
4357 hits | 71.71 KB | Posted: 7/12/06
(Posted in: Panther Body/Chassis/MISC diagrams and pinouts)

Head Install.jpg
4360 hits | 43.21 KB | Posted: 1/2/05
CAUTION: Failure to position crankshaft as shown will cause damage to pistons and/or valve train components.

NOTE: With crankshaft in this position, no piston will be at TDC.
(Posted in: Diagrams)

Dashboard View From Right.jpg
4363 hits | 78.6 KB | Posted: 1/3/05
(Posted in: Interior)

PDRM0145.JPG
4363 hits | 41.48 KB | Posted: 10/22/06
the 98-02 Conti floor shifter

It is pretty much identical to the 2001 LX Sport, Marauder and LSE shifter units but with some metal mounting tabs on the front

It's also ~1/2" taller!
(Posted in: Center Console & Floor Shifter Conversion (9/'05))

RASspring.JPG
4385 hits | 15.01 KB | Posted: 1/21/07
http://www.crownvic.net/drock96marquis/RAS.htm

1998 and up Panther RAS base-rate airspring extended
(Posted in: TECH/MISC -- Click for MISC tech pics-SEE SUBS)

17Done.JPG
4388 hits | 59.76 KB | Posted: 11/21/06
The old coil probably still works fine, but I decided to replace it anyway. Same for the spark plug, if I had regapped it, but the boot was chewed up.
(Posted in: Spark Plug)

Buckle6.jpg
4392 hits | 65.08 KB | Posted: 1/15/06
Since I also wanted to wash the seat belts, I disassembled the buckle.

It's common for this spring to fatigue & break, which can lock the buckle. But it's common to all Fords with this shape of buckle, so it's easy to find one in a junkyard & swap ...
(Posted in: Seats & Belts)

ParkBrake98Spec.jpg
4403 hits | 21.5 KB | Posted: 7/28/05
Park Brake Adjustment

Center parking brake shoe and linings on parking brake support plate and, using an 8-inch micrometer, gauge parking brake shoe and linings to dimensions shown.
(Posted in: Diagrams)