P6250041.JPG
8056 hits | 82.16 KB | Posted: 6/26/05
(Posted in: Factory Tech Valve Body install)

Axle ID 87-90.jpg
8057 hits | 59.09 KB | Posted: 7/26/03
Axle '87-90 Applications

. [url=http://www.supermotors.net/registry/media/170512][img]http://www.supermotors.net...
(Posted in: Diagrams)

FuelPumpEarlyEFI.JPG
8059 hits | 73.5 KB | Posted: 10/12/10
Hi-Pressure Fuel Pump, Filter, & Dual-Function Reservoir F1UZ-9B263-B for '84-89 EFI
IF THE IMAGE IS TOO SMALL, click it.

[url=http://www.supermotors.net/registry/media/507187][img]http://www.supermoto...
(Posted in: '84-89 Fuel Reservoirs)

RABS Troubleshooting 92.jpg
8069 hits | 67.8 KB | Posted: 1/13/06
RABS & RABS-II Troubleshooting
IF THE IMAGE IS TOO SMALL, click it.

Flashout Codes

Whenever the yellow REAR ABS light comes on during normal operation, a flashout code may be obtained to aid in problem diagnosis. If the vehicle is shut off before t...
(Posted in: Brakes & Hubs)

Axle ID 91-93.jpg
8070 hits | 69.08 KB | Posted: 7/26/03
Axle '91-93 Applications

. [url=http://www.supermotors.net/registry/media/170512][img]http://www.supermotors.net...
(Posted in: Diagrams)

Tire Carrier Inside.jpg
8070 hits | 53.49 KB | Posted: 10/14/05
Inside Tire Carrier

. [url=http://www.supermotors.net/registry/media/795680][img]http://www.supermo...
(Posted in: Diagrams)

Rack Ready.JPG
8078 hits | 63.26 KB | Posted: 7/13/03
I cut the front of the tracks down by 1 screw hole and installed 2 rear crossbars because they can both be (re)moved without tools. The original front bar is screwed in place, so I deleted it. I also added more tie-downs.

Outside dimensions (after...
(Posted in: Camper Shell & Sliding Side Windows)

Timing Pointer.JPG
8091 hits | 102.12 KB | Posted: 7/11/03
Timing Pointer & Misfire Sensor used only on '96 OBD-II smallblock engines. The lower L pulley is a factory idler where the unneeded air pump used to go. The '96 cats are Oxygen-storing, so they don't need 2ndry air.

[url=http://www.supermotors.ne...
(Posted in: Base Album)

J 1.JPG
8093 hits | 94.38 KB | Posted: 7/12/03
Lock Ring
Cleaning also makes it much easier to turn the ring.
(Posted in: '90-96 Fuel Pump System)

Wire Unclipped.JPG
8107 hits | 36.81 KB | Posted: 11/29/04
To get enough slack in the wire to pull the motor out & work on it, remove the clip from the bottom of the tailgate. Remember to reinstall it later, or the wire could become entangled in the glass or regulator.

That hook on the L side is the bott...
(Posted in: Tailgate Tech)

Picture 013.mpg
8118 hits | 1.41 MB | Posted: 9/29/03
(Posted in: videos)

BattTermLF.JPG
8118 hits | 63.31 KB | Posted: 4/28/09
Late-Model OE-style Battery Terminals ~$10ea @ NAPA

The "lead-free" description is misleading. The other solder-on terminals are also lead-free; they're brass or copper with a tin or silver-solder coating.

But this style may be a better ...
(Posted in: Solder-On Battery Terminals)

T-case95EVTM.jpg
8119 hits | 36.09 KB | Posted: 1/22/05
ESOF T-Case 95 Bronco
IF THE IMAGE IS TOO SMALL, click it.

. [url=http://www.supermotors.net/regist...
(Posted in: Diagrams)

26WinchRelays.JPG
8120 hits | 65.78 KB | Posted: 11/22/12
Like the battery, alternator, & any other high-current connections, the winch relay terminals need maintenance. I labelled each strap & wire, disassembled & polished every mating surface, applied electrical grease, then reassembled it. I plan to ge...
(Posted in: Build)

TirePressures92.JPG
8129 hits | 115.33 KB | Posted: 10/24/10
Tire Sizes & Pressures 1/2-ton

See also:
. [url=http://www.supermotors.net/registry/media/491879_1][...
(Posted in: Diagrams)

FrameWiring.JPG
8135 hits | 40.61 KB | Posted: 6/30/12
'90-96 Bronco Frame Wiring
IF THE IMAGE IS TOO SMALL, click it.

'87-89 also has a takeout near 6 for the frame fuel pump.

[url=http://www.supermotors.net/registry/media/935111][img]http://www.supermotors.net/getfile/935111/thumbnail/13framewire.jpg...
(Posted in: Diagrams)

Oil Flow.jpg
8163 hits | 61.46 KB | Posted: 1/2/05
Oil flow for 4.6L modular engine
(Posted in: Diagrams)

03DashLoose.JPG
8177 hits | 90.85 KB | Posted: 11/11/05
There's no need to disconnect the wiring or vacuum lines on the driver's side since this provides enough access to work. With the hoses & 3 nuts already removed, the box can now be pulled from the firewall. The top stud has a push-nut holding it to...
(Posted in: Heater Core)

C418.JPG
8185 hits | 66.26 KB | Posted: 9/12/07
This is all the wiring for the tailgate, except the ground for the defrost grid. This connector is located inboard of the L frame rail between the rear bumper & the gas tank rear crossmember.

[url=https://www.supermotors.net/registry/media/1172069]...
(Posted in: Tailgate Tech)

FuelLines91.JPG
8201 hits | 62.19 KB | Posted: 5/1/12
'86-91 Fuel Lines

Garter Spring Safety Clips w/tethers
9mm E7AZ9A317A (E7AZ9A317AA)
12.5mm E7AZ9A317B (E7AZ9A317BA)

[url=https://www.supermotors.net/registry/media/950180_1][img]https://www.supermotors.net/getfile/950180/thumbnail/fuelflow.jpg[/img...
(Posted in: '90-96 Fuel Pump System)

DetroitLockerD80.JPG
8208 hits | 79.94 KB | Posted: 3/16/07
Detroit locker offered as OE in some Ford Dana 80 rear axles.

1 Case Assy.
2 Thrust Washer
3 Side Gear
4 Preload Dampener Kit
5 Spring Retainer
6 Spring
7 Clutch Assy.
8 Central Driver Assy.
9 Case Bolt (8 Req'd.)

The locking differen...
(Posted in: Diagrams)

B6.JPG
8208 hits | 94.17 KB | Posted: 7/13/03
Install Caliper Slide Clips (Ford F2TZ2C150A; MC BRCK5030) with locking tabs facing the steering knuckle. They should also have a light coat of brake grease where they touch the caliper, and those surfaces should be otherwise clean.

[url=https://ww...
(Posted in: Brakes & Hubs)

Disc8.8Axle04E150.JPG
8211 hits | 77.46 KB | Posted: 5/16/07
Disc 8.8" from '04-06 E150 with 5x5.5" lug spacing requires 16" rims
IF THE IMAGE IS TOO SMALL, click it.

1 Rear axle identification tag (part of 4001)
2 Differential housing cover bolt 4346
3 Differential housing cover 4033
4 D...
(Posted in: Brakes & Hubs)

Key Card.JPG
8219 hits | 36.41 KB | Posted: 9/12/05
TSB 92-08-04 Cutting Plastic Keys
Publication Date: APRIL 8, 1992

FORD: 1991-92 CROWN VICTORIA, ESCORT, MUSTANG, PROBE, TAURUS, TEMPO, THUNDERBIRD
LINCOLN-MERCURY: 1991-92 CAPRI, CONTINENTAL, COUGAR, GRAND MARQUIS, MARK VII, SABLE, TOPAZ, TOWN CAR...
(Posted in: TSBs & FSAs (Recalls) for '83-96 Broncos & F150s)

DashPad92-96.jpg
8231 hits | 40.44 KB | Posted: 10/16/05
'92-96 Dash Pad

. [url=https://www.supermotors.net/registry/media/1127378][img]https://www.supermotors.net/getf...
(Posted in: Diagrams)

Airbag Falsing Sensor.JPG
8237 hits | 56.45 KB | Posted: 11/25/05
Bronco airbag safing sensor at base of R B-pillar '94-96 ONLY.

See also:
. [url=https://www.supermotor...
(Posted in: General Purpose Pics)

TPS chart 1.jpg
8244 hits | 88.88 KB | Posted: 1/29/05
TPS Application Chart CARS

See this diagram for TRUCKS:

See this diagram for testing:
[url=http://www.superm...
(Posted in: Diagrams)

ChokeHeatTube.JPG
8250 hits | 61.87 KB | Posted: 11/9/11
Choke Heater Tube

The choke housing on the carburetor has a restricted journal to vacuum, which draws air in from the fiber-wrapped heat tube. The tube comes from a fitting on the exhaust manifold connected to a pass-through tube that collects heat...
(Posted in: Diagrams)

EVPgraph.jpg
8262 hits | 23.89 KB | Posted: 6/30/09
EVP Output Graph

Voltage is measured from the Br/LG wire (EVP) to Gy/R (SigRet) with the key in RUN and the sensor connected normally. Check Br/Wh (VRef) to Gy/R for 5VDC. Use a handheld vacuum pump (e.g. MityVac) to operate the EGR valve.

[url=h...
(Posted in: Diagrams)

Module 1.JPG
8262 hits | 110.09 KB | Posted: 7/12/03
Reservoir Removal
Remove the level sender upper mounting screw, press & hold the lock clip down, then lift the tube assembly from the reservoir.

The reservoir (which contains the pump, the return valve, & the pickup siphon) is interchangeable betwee...
(Posted in: '90-96 Fuel Pump System)

T-caseShifter92.jpg
8274 hits | 35.51 KB | Posted: 4/18/07
TSB 93-2-11 Buzz or Rattle through the 4X4 Manual Shift Lever
Publication Date: JANUARY 18, 1993

Applies to: LIGHT TRUCK: 1992 BRONCO, F-150-350 SERIES

ISSUE: A "buzz" or "rattle" may be heard through the 4X4 transfer case shif...
(Posted in: TSBs & FSAs (Recalls) for '83-96 Broncos & F150s)

P9290025.JPG
8277 hits | 71.66 KB | Posted: 9/29/05
Keeping tension on the belt by propping it up with a screwdriver while the alternator gets removed.
(Posted in: Alternator Replacement)

TGSwitch1.JPG
8294 hits | 50.5 KB | Posted: 5/17/07
Tailgate Window Switch

The switch is actually 2 SPDT microswitches which aren't designed to be separated from the harness. They're riveted to the casting that slips over the lock cylinder, with a cover plate on top.
(Posted in: Tailgate Tech)

Filler.JPG
8295 hits | 84.1 KB | Posted: 7/12/03
Filler Neck
Loosen the hose clamp at the tank & pull the outer filler neck off the tank. There is another hard plastic hose inside ('87-96), which also must be guided out of the tank.

The extra bolts in the body are for the dealer-option 3rd-row ju...
(Posted in: '90-96 Fuel Pump System)

EUL-IMS.jpg
8337 hits | 76.08 KB | Posted: 4/10/06
EMW/IMS(EUL) COMBO module, found on the back of the instrument cluster in '87-89 V8s.

Emissions Maintenance Warning / Inferred Mileage Sensor
[url=http://www.supermotors.net/registry/media/544459][img]http://www.supermotors.net/getfile/544459/thumbn...
(Posted in: TSBs & FSAs (Recalls) for '83-96 Broncos & F150s)

Alt94Tbird.JPG
8337 hits | 103.74 KB | Posted: 9/20/07
This is going to replace the crappy '88 2G alternator. The 130A 3G alternators are easily identifiable by the 2 large holes between each pair of ribs on the front case. Those with 4 holes are 95A.

[url=https://www.supermotors.net/registry/media/10...
(Posted in: Phase 3)

AutelAL309.jpg
8338 hits | 61.99 KB | Posted: 6/18/09
Autel.us AutoLink AL309



For under $30, this reads & clears OBD-II codes ('96-up), and displays PIDs (li...
(Posted in: General Purpose Pics)

ExhaustEFI.JPG
8340 hits | 61.05 KB | Posted: 7/19/12
1/2-ton EFI Exhaust
IF THE IMAGE IS TOO SMALL, click it.

Before madly ripping out all the emissions systems on your vehicle, read this article.

'95-96 MAF has 2 up...
(Posted in: Diagrams)

FuelLines92.JPG
8346 hits | 65.1 KB | Posted: 5/1/12
'92-96 Fuel Lines (gas)


(Posted in: '90-96 Fuel Pump System)

Relays2.jpg
8348 hits | 81.25 KB | Posted: 4/21/07
Working on ONE relay at a time, remove the terminals from the stock connector & discard it. I collected these Bosch-style sockets in junkyards, but they're available at most parts stores, from Ford, or several online suppliers like [url=https://www....
(Posted in: Phase 3)

CruiseVacuum92Dash.jpg
8350 hits | 61.63 KB | Posted: 11/9/05
Vacuum Cruise Underdash

See also:
. [url=http://www.supermotors.net/vehicles/registry/media/894...
(Posted in: Diagrams)

52Boogers.JPG
8353 hits | 80.05 KB | Posted: 1/4/12
I don't even think MY welds are that bad! (Well, maybe...)
(Posted in: Body Donor #2)

FX-10Compressor.JPG
8373 hits | 52.88 KB | Posted: 5/3/07
FX-10 Compressor

Type: swashplate with 5 double-acting axial pistons
Displacement: 10.4 CI (170cc)
Bore: 29mm
Stroke: 25.7mm
Rotation: CW
Rational Torque (no load): 13 Nm (9.6 ft-lb)
Oil (for R-134a Refrigerant): YN-12b (F2AZ-19577-AC)
Syste...
(Posted in: Diagrams)

Fusebox-Dashboard.jpg
8380 hits | 54.62 KB | Posted: 6/22/07
This diagram is for the fusebox located inside the truck, on the lower left side of the dashbaord on a '96 Bronco.
(Posted in: Misc. Bronco Information (diagrams, etc.))

bronco-4-2006_037.jpg
8397 hits | 66.85 KB | Posted: 4/25/06
give a sharp blow with hammer, re-tighten nuts if needed
(Posted in: axle pivot bushing tool)