1995 Ford Bronco
| Owner: |
jam0o0 (All of this user's registries on SuperMotors) |
| From: |
Houston, TX, U.S.A. (Other registries in TX) |
| Year, Make, & Model: |
1995 Ford Bronco (Other Ford Broncos) |
| Avatar: |
 |
| Clubs: |
FullSizeBronco.com (Other vehicles in this club)
2 Big Broncos (Other vehicles in this club)
|
| Nickname: |
|
| Mileage: |
120000 |
| Engine: |
351 w, rebuilt, mild port on exhaust ports, mild cam
-head elite long tube headers with EGR and O2 sensor provisions (i built)
-custom 2.5inch y-pipe (i built)
-dual 2.5in highflow cats
-flowmater 50 series 3inch in 2.5 inch dual out. goes over frame to tips in front of rear tire. one on each side
-150 amp alt,
-york air compressor out of a volvo |
| Drivetrain: |
E4OD,
NWF eco box doubler
- gears from an NP 273
-custom machined to fit NP 273 input shaft, bearing and seal.
NP205
- refurbished
-shift rails ground for twin stick
- high angle driveline parking brake
D60, 5.13 gears, ARB air locker, 35spline 4340 outers and 4340 long side inner, spicer u-joints, heavy plated dif cover
Sterling 10.25, 5.13 gears, Detroit no-spin, disk brakes, caged dif cover, u bolt yolks
rear drive shaft: 1350 cv -3"od, .25 wall 1410 u-joint axle end
front drive shaft - 1410 axle end, 1350 cv, flange, 1350 at transfercase |
| Notes: |
this truck spent time in Texas then upstate New York. so it's not in the best shape but it's not bad.
Front Suspension (i built)
-front TTB axle swapped for D60
-moved 1" forward
-'79 coil buckets
-'90's f350 shock mounts, extended
- radius arms, 2x.25 DOM with hym and poly joints
-track bar, 3/4 hyme and 1.5x.25 DOM tubing
-6" '79 bronco coil springs
-14" travel bilsien 5150 shocks
-new trans crossmember
-.25" wall DOM steering with Chevy one ton TRE's
Rear Suspension (i built)
-rear end moved 3 inches back
-6" lift springs with overloads removed
-shackle flip and longer shackle
-12" travel procomp shocks
mods
-dual optima yellow top batteries
-g3 150 amp alternator
-1/0 gauge wires
-York 210 air compressor, complete OBA system. rear bumper is air tank. gauge mounted in cab.
-4ft black firestic CB antenna. mounted to rear bumper
-40 channel CB
-race trim suspension seats, on factory sliders
Hydro assist steering
-2.5" single ended ram from PSC
-saginaw p-pump retrofit, PSC can, and pump
-1/2 gallon remote res
-big cooler
-spin on filter
-PSC tapped steering box
- all line 3/8 JIC
Armor
-rear bumper, single 4.5in tube w/ receiver, 3/8 in wall steel, it's the air tank (i built)
-rock sliders, 2x5x.25 rectangle rocker replacement style. (i built)
-front bumper, 4.5x.125 tube, 1/4 inch plate, holds MileMarker 12000 lb. electric winch, and 1/2 inch plate tow points. (i built)
-gas tank - lower half 1/4" plate with factory top half (i built)
body
-cut-out rear fenders and rear body corners
-cut out front fenders and made new inner fenders
-6inch eyebrow
-sound deadening, three layers on tailgate, three layers in doors.
-all carpet pulled
Stereo - on hold til new dash i built
-pioneer CD, MP3, satellite radio head unit
-Diamond Audio D 3: 6.5 inch components
-Pioneer 4 channel amp powering those
-1/0 gauge power wires, switches for amp's remote turn on located on switch pannel,
Gauge package - on hold til new dash is built
-tranny temp and water temp gauges in 2 gauge pod on A pillar. oil pressure and air pressure for OBA along with a clock in the stock radio location |
| Last Updated: |
11/24/2021 |
| Hits: |
84429 |
| Folder |
 |
 |
 |
Hits |
 |
Created |
Updated |
 bronco pics | 22 | 0 | 0 | 14,531 | 0 | 6/23/05 | 1/25/09 | | metal stuff | 4 | 0 | 0 | 2,564 | 0 | 7/5/05 | 1/5/07 | | rear bumper | 10 | 0 | 0 | 5,716 | 0 | 1/5/07 | 7/20/08 | | rock sliders | 3 | 0 | 0 | 1,890 | 0 | 1/27/07 | 1/23/09 | | front bumper | 6 | 0 | 0 | 3,601 | 0 | 7/6/08 | 2/22/09 | | Armored Gas Tank | 4 | 0 | 0 | 1,894 | 0 | 11/14/09 | 11/14/09 | | roof rack | 15 | 0 | 0 | 5,328 | 0 | 3/27/11 | 3/27/11 | | sound deadenning | 12 | 0 | 0 | 18,110 | 0 | 9/4/05 | 12/11/05 | | electrical | 20 | 0 | 0 | 15,798 | 0 | 9/4/05 | 3/18/07 | | exhaust | 3 | 0 | 0 | 2,121 | 0 | 10/23/05 | 10/23/05 | | version two | 23 | 0 | 0 | 11,075 | 0 | 1/17/10 | 2/26/10 | | engine | 2 | 0 | 0 | 1,111 | 0 | 12/11/05 | 2/22/06 | | Engine rebuild etc | 6 | 0 | 0 | 1,683 | 0 | 7/23/15 | 7/23/15 | | interior | 6 | 0 | 0 | 5,928 | 0 | 2/22/06 | 2/22/06 | | sterio | 15 | 0 | 0 | 8,245 | 0 | 7/5/05 | 8/14/08 | | seats | 5 | 0 | 0 | 2,584 | 0 | 11/16/09 | 11/19/09 | | exterior | 1 | 0 | 0 | 457 | 0 | 4/5/06 | 4/5/06 | | rear fender stuff | 8 | 0 | 0 | 3,914 | 0 | 1/14/07 | 1/27/07 | | one tons | 6 | 0 | 0 | 4,062 | 0 | 5/4/06 | 10/26/06 | | 10.25 rear | 9 | 0 | 0 | 5,567 | 0 | 5/5/06 | 10/19/06 | | front dana 60 | 6 | 0 | 0 | 4,676 | 0 | 4/5/06 | 10/19/06 | | SAS | 74 | 0 | 0 | 42,818 | 0 | 3/13/08 | 3/28/09 | | front sys | 28 | 0 | 0 | 14,129 | 0 | 8/6/08 | 5/1/09 | | OBA | 10 | 0 | 0 | 5,204 | 0 | 10/26/06 | 3/29/07 | | vers 2 | 5 | 0 | 0 | 891 | 0 | 11/1/17 | 11/1/17 | | winch | 5 | 0 | 0 | 2,599 | 0 | 10/26/06 | 10/26/06 | | for sale | 76 | 0 | 0 | 27,439 | 0 | 4/5/06 | 3/7/19 | | other | 13 | 0 | 0 | 7,016 | 0 | 5/5/06 | 9/3/10 | | wheeling | 0 | 0 | 0 | 0 | 0 | 4/6/09 | 4/6/09 | | ranch 6-2005 | 8 | 0 | 0 | 4,560 | 0 | 9/4/05 | 4/6/09 | | ranch 6-07 | 0 | 0 | 0 | 0 | 0 | 4/6/09 | 4/6/09 | | spring creak 4-2009 | 28 | 0 | 0 | 14,360 | 0 | 4/6/09 | 4/6/09 | | spring creek 5-2009 | 6 | 0 | 0 | 2,687 | 0 | 5/11/09 | 5/11/09 | | katempcy 5-2009 | 86 | 0 | 0 | 38,701 | 0 | 5/28/09 | 5/28/09 | | others | 64 | 0 | 0 | 25,925 | 0 | 5/28/09 | 5/28/09 | | Barnwell 09/09 | 57 | 0 | 3 | 34,306 | 0 | 10/18/09 | 3/31/11 | | BVORR 11/09 | 23 | 0 | 0 | 10,089 | 0 | 12/1/09 | 3/31/11 | | M&G 6-2010 | 6 | 0 | 0 | 2,817 | 0 | 6/20/10 | 6/20/10 | | BVORR 10-2010 | 10 | 0 | 0 | 5,438 | 0 | 10/12/10 | 7/25/13 | | Barnwell 10/2010 | 33 | 0 | 0 | 14,383 | 0 | 10/18/10 | 3/31/11 | | hidden falls 10-2012 | 230 | 0 | 0 | 54,988 | 0 | 10/28/12 | 11/1/12 | | barnwell mountain 10-2014 | 146 | 0 | 0 | 28,570 | 0 | 10/29/14 | 10/29/14 | | Barnwell 2016-10 | 5 | 0 | 0 | 773 | 0 | 6/7/17 | 10/31/17 | | Barnwell 2017-10 | 22 | 0 | 0 | 2,587 | 0 | 10/31/17 | 10/31/17 | | Ranch 2018-03 | 6 | 0 | 0 | 883 | 0 | 3/21/18 | 3/21/18 | | Barnwell 2019-10 | 3 | 0 | 0 | 725 | 0 | 10/28/19 | 10/28/19 | | Barnwell 10-21 | 0 | 0 | 0 | 0 | 0 | 10/26/21 | 10/26/21 | | shop 2013 | 53 | 0 | 0 | 12,674 | 0 | 9/15/13 | 12/16/13 | | 2015 | 6 | 0 | 0 | 1,868 | 0 | 3/9/15 | 3/9/15 | | 2017 | 13 | 0 | 0 | 1,813 | 0 | 8/15/18 | 8/16/18 | | 2018 | 1 | 0 | 0 | 254 | 0 | 8/16/18 | 8/16/18 | | shop 2021 | 3 | 0 | 0 | 406 | 0 | 11/21/21 | 11/21/21 | | New Shop 2021 | 27 | 0 | 0 | 3,920 | 0 | 11/21/21 | 11/24/21 |
 tailgate sound dead.JPG
1772 hits | 63.41 KB | Posted: 9/4/05
that's the best pic i could get of the sound deadening in the tailgate.
 inner door pannel after peal and seal.JPG
1734 hits | 66.31 KB | Posted: 11/3/05
inner door pannel after peal and seal. i might stick the old factory stuff on too. haven't decided yet.
 sound deadening door 1.JPG
1703 hits | 54.88 KB | Posted: 12/11/05
outer door skin lined
 a-pillar gauge pod 2.JPG
1700 hits | 52.3 KB | Posted: 2/22/06
i mounted the gauges as low as posible to try to keep them out of my field of vission. no rattling against the dash and very little lost visibility.
 door pannel crack.JPG
1625 hits | 25.04 KB | Posted: 11/3/05
o and this
 door light missing.JPG
1616 hits | 35.85 KB | Posted: 11/3/05
something else i need to fix wile everythign is taken apart
 sound deadening door 3.JPG
1612 hits | 44.29 KB | Posted: 12/11/05
i didn't get as much sound reduction as i was hoping for. i may try another layer since i have the extra. but that wont be till i have some new door speakers.
 door pannel inner before .JPG
1588 hits | 68.86 KB | Posted: 11/3/05
door pannel before with stock capet padding sound deadening removed.
 door before.JPG
1554 hits | 41.97 KB | Posted: 11/3/05
inside door before with water barrior
Maintenance & Modification Logs
| Date | Type | Mileage | Title / Description | $ Amount | | 10/07/10 | Miscellaneous | 126000 | test drive
steering is slow to respond when changing direction. has plenty of power to break things when you get to the steering stops.
headers are quiet at idle. but LOUD when you step on the gas.
exhaust pointed at body panels makes panel hot and smells funny.
disconnected factory oil pressure sender. no effect
braded stainless for new oil pressure line in engine compartment.
| 0.00 | | 10/05/10 | Maintenance | 126000 | brake booster replace
had brake petal that stayed down.
replaced booster with reman unit.
old booster inner rod was rusted from the inside. weird.
| 0.00 | | 06/30/10 | Modification | 126000 | steering
power steeing-
pump bracket from a van
new delfi pump from a van
new gear box - tapped for hydro assist
new van high pressure hose
psc 1.5x8 ram
braided stainless -6 hoses
ebay aluminum fluid reservoir
psc pump can
-10 suction line and fittings
hydraulic fluid filter - 3/8 npt ports - surplus center
shit still doesn't work | 0.00 | | 02/01/10 | Modification | 126000 | exhaust
headman elite long tubes
2.5 mandrel bent
2.5 magnaflow offset cats
flowmaster 50 series
| 0.00 | | 10/13/09 | Miscellaneous | 126000 | fall run, gilmer
broke passenger side tail light.
shift linkage for transmission is way screwed.
passenger side core support mount completely broken | 0.00 | | 07/30/09 | Maintenance | 126000 | fuel filter
replace fuel filter. had to get a special tool for the new "easier to work on" fuel lines
fuel filter - napa gold
tool - also can be used for A/C lines. not sure how but that's what it says. $6 at advanced
made new gas tank - pump and other stuff looks good. | 0.00 | | 07/12/09 | Maintenance | 126000 | spark plug
changed spark plugs - used autolight coppers gapped to .05-.06. old ones all look similar. definetly worn. had motorcraft before.
| 0.00 | | 07/11/09 | Maintenance | 126000 | change oil and filter
microgard mini filter
mobil 1 5-w30 | 0.00 | | 03/30/09 | Maintenance | 126000 | one ton swap record
every bearing and seal in the front and rear axles are new, gears, fluid, tires is new. | 0.00 | | 10/07/07 | Damage | 123500 | wheeling at ranch
front not engaging again. nothing visually wrong with anything without tearing it down. | 0.00 | | 10/01/07 | Maintenance | 123000 | oil
oil change, mobil one again. old oil looked good.
also tightened oil pressure line. | 50.00 | | 09/15/07 | Damage | 122000 | warn hub
got a set of new warn hubs. only put in drivers side. old one lost a snap ring. | 110.00 | | 06/07/07 | Repair | 120000 | water pump
replaced leaking water pump with duralast unit. 35$ also changed coolant and thermostat. drilled and taped water neck for autometer temp sensor. | 60.00 | | 06/07/07 | Maintenance | 121000 | wheel bearings
replaced wheel seals and all front wheel bearings. used napa stuff. cleaned and regreased lockouts too. painted knuckles and hubs as well. | 150.00 | | 06/02/07 | Maintenance | 121000 | changed oil
changed oil and filter. used valvoline again. old oil was just as dirty looking as mobil 1 after many more miles. | 0.00 | | 03/21/07 | Maintenance | 120000 | change oil
changed oil and filter. put in valvoline. | 0.00 | | 12/12/06 | Maintenance | | new TRE
replces all the TRE's | 0.00 | | 12/11/06 | Maintenance | | changed oil
changed the oil used mobil 1 extended performance. | 0.00 | | 07/29/06 | Maintenance | 112000 | replace aux tranny filter
i hear you aren't suppost to let the first filter stay on there too long. oopse. well 7000 miles isn't that bad i guess. | 15.00 | | 05/30/06 | Miscellaneous | 110000 | drive from Rochester to Houston
1500 miles. pulling 12 foot u-haul. average 12MPG | 300.00 | | 02/22/06 | Modification | 106200 | new door speakers
got new Diamond Audio D3 components
6 inch mid bass driver
1 inch tweeter
ajustable crossover
comes with, grills, flush or surface mount cups and hardwear for tweeters
and grills, mounting rings, hardwear for drivers | 170.00 | | 02/15/06 | Modification | 106000 | transmistion filter
added an external transmision filter. the mount canme with a place for a temp sensor. hooked it up backwards and drove with it like that for 15 miles. then switched the hoses.
funnel - $3
fluid - $3
filter - 13
mount - 25
hoses, fitings, clamps - 10 | 50.00 | | 01/21/06 | Maintenance | 105600 | wires, cap, rotor
replaced cap and rotor (MSD, red, w/ wire hold down thing)
sparkplug wires (9mm Ford Racing, red)
had to get dielectric grease too
| 65.25 | | 12/06/05 | Modification | 105400 | MSD ignition coil
replaced the factory coil with a 48K volt MSD coil. the factory one was pitted or something on the end going to the distributor. i swapped in the dark in a poorly lit parking lot. it was 10* and i didn't have gloves. and it was still as easy as a changing my airfilter.
the truck revs much smoother now and it sounds less like it's dieing at high RPM. | 40.00 | | 11/04/05 | Maintenance | 104500 | change oil
the last oil change was at 96k and i used 15k mile oil but it was the first bunch. so i'm changing it now again. i'm using mobil1 5w30 extended performance. and a not fram filter | 45.00 | | 11/02/05 | Modification | 104500 | sealed air intake
covered air intake with insulation and finished it with aluminum tape. should help with getting cooler air to engine. | 15.00 | | 09/25/05 | Maintenance | 103800 | changed to mud tires
i changed out the cooper street tires for some 30X9.5 Procomp MTs. i had the new tires on 15X8 black steel bart racing wheels. 3 inch backspacing. also got full metal value stems. (price is without tires.) | 275.00 | | 08/28/05 | Miscellaneous | 102000 | drive from houston to rochester
drove from houston to rochester. took 4 days. average mpg for trip was 15. truck was full. | 250.00 | | 01/13/05 | Repair | 91400 | replace oil pan
pan rusted through
replaced pan,
changed oil
new exhaust fasseners | 1,050.00 | | 11/29/04 | Repair | 90800 | first repairs after purchase
replaced -
-all 6 shocks
-upper ball joint
-lower ball joint
-inner and outer tie rod ends
-drag link
-radius arm bushing
-front alignment
-rear brake shoes
-resurfaced drums
-rear wheel cylinder
-timing chain
-change oil
-water pump
-thermostat
-upper and lower radiator hoses
-front coil springs
-air filter | 4,260.00 | | Total | 6,905.25 |
|
|
