Leak02.JPG
3147 hits | 56.44 KB | Posted: 2/8/06
To fix the leak, remove the RF wheel & peel the wheelwell liner forward. Clean & dry the area under the drain.
(Posted in: Rain Leak)

TPS graph.jpg
3148 hits | 34.45 KB | Posted: 12/4/04
TPS Output Graph
(Posted in: Diagrams)

EngineTB.jpg
3153 hits | 82.16 KB | Posted: 11/7/03
(Posted in: Engine)

bullitt rims 002.jpg
3154 hits | 64.26 KB | Posted: 6/26/04
Bullitt 2
(Posted in: Bluestreak)

Piston Bore Micrometer.jpg
3157 hits | 43 KB | Posted: 1/2/05
NOTE: After any refinishing operation, allow cylinder bore to cool, and ensure piston and bore are clean and dry before piston fit is checked.

1. Calculate size piston to be used by taking a cylinder bore check. Follow procedures outlined previous...
(Posted in: Diagrams)

1999-P71-eBay-04.jpg
3158 hits | 78.66 KB | Posted: 5/14/04
1999 P71 (eBay) - 04
(Posted in: 1999 P71 (eBay))

Roof02.JPG
3163 hits | 73.43 KB | Posted: 12/14/06
LHS welded patches, & roof bows used only in P71s. They're bolted & glued in, and they interfere with civilian headliners.
(Posted in: Headliner "Repair")

05Levers.JPG
3164 hits | 49.53 KB | Posted: 12/5/06
While the brakes & hardware are completely out of the way, clean any steel filings from the ABS sensor & tone ring, remove any heavy brake dust deposits, & apply a small amount of grease to the shoe pads on the backing plate. There are 2 pads on eac...
(Posted in: E-Brake Shoes)

Panel Removed1.JPG
3166 hits | 63.43 KB | Posted: 6/15/05
(Posted in: Custom gauge cluster trim panel.)

SpeedoGear.JPG
3186 hits | 55.91 KB | Posted: 11/28/10
Using the mfr's diameter in Liquid's calculator, the gray 19-tooth gear in the car should be correct, but the speedo showed ~9% high. Using the tire's rolling diameter of 25.79" (back-ca...
(Posted in: Vicky)

ADM 95 code12.jpg
3190 hits | 46.6 KB | Posted: 3/28/05
DTC 12: LOST BATTERY FEED

Normal Operation

The air bag diagnostic monitor measures the voltage at Pin 14 of the air bag diagnostic monitor connector. Voltage at Pin 14 should be equal to battery voltage. If the voltage at Pin 14 drops to less...
(Posted in: Diagrams)

StudClearance.JPG
3192 hits | 48.07 KB | Posted: 12/5/06
Rotate the hub so there's ample clearance behind the stud to be removed, then drive it inward with a hammer until its splines clear the hub flange. Install a new lug stud, using a stack of washers & a lug nut to pull it into the hub flange. Torque ...
(Posted in: E-Brake Shoes)

DoorLocks92.jpg
3194 hits | 57.16 KB | Posted: 2/6/05
Door Locks w/o Keyless Entry or Driver's Door Module (Old-style)
(Posted in: Diagrams)

ABSSchem96.jpg
3199 hits | 42.28 KB | Posted: 4/20/05
ABS Schematic 1996
(Posted in: Diagrams)

Lower Steering Column Cover Remove.JPG
3208 hits | 50.04 KB | Posted: 6/15/05
(Posted in: Custom gauge cluster trim panel.)

9C1 Sticker.jpg
3210 hits | 21.16 KB | Posted: 11/6/03
A "Notice:Use Overdrive During High Speed Pursuit" decal from a 9C1 Caprice.
(Posted in: Interior)

headers3.jpg
3215 hits | 65.7 KB | Posted: 9/28/03
Ford Racing shorty headers with a custom EGR tube.
(Posted in: Parts)

CarpetBottom.JPG
3228 hits | 86.71 KB | Posted: 2/8/06
I pulled my carpet to dry it out. The passenger side (R in the photo) is wet & rusty from the leak on the firewall at the HVAC drain.
(Posted in: Rain Leak)

Trans2.JPG
3232 hits | 73.41 KB | Posted: 3/6/05
The transmission, with the pan removed.
(Posted in: J-mod and transmission and underside pics.)

Seats03CV.JPG
3238 hits | 76.44 KB | Posted: 9/13/06
Power Seats 03 Crown Vic & Grand Marquis (not Marauder)
(Posted in: Diagrams)

01Tailhousing.jpg
3251 hits | 54.41 KB | Posted: 4/17/05
Before. Tailhousing bushings are prone to wear because they are only lubricated by the splash of fluid running up inside the tailhousing. The wear leads to driveshaft vibration, noise, & premature transmission failure. The common patch is to simpl...
(Posted in: Forced Lube)

1979 ltd steering wheel.jpg
3257 hits | 11.7 KB | Posted: 3/28/07
The '79-'82 Steering Wheel, with leather wrapping and cruise control.

Notice the 1979-unique CV speedometer in the background.
(Posted in: 1979)

Wreck18.jpg
3265 hits | 58.32 KB | Posted: 12/18/06
I cleaned up most of the debris off the road.
(Posted in: Wreck)

03Guts.jpg
3269 hits | 52.27 KB | Posted: 1/15/06
I had planned to use the '93 cushions, but their wire reinforcements don't match my upholstery, so I reused my pads. I added some wire to reinforce the front retainers for the seat springs - they were broken on this seat, and my original.
(Posted in: Seats & Belts)

FPR.jpg
3275 hits | 48.55 KB | Posted: 12/4/04
FPR
(Posted in: Diagrams)

PowerWindows96p3.jpg
3279 hits | 66.2 KB | Posted: 1/9/05
96 CV Power Windows p.100-3
(Posted in: Diagrams)

CarbonCanisterLines.jpg
3282 hits | 47.12 KB | Posted: 1/11/05
EVAPS Lines

The Fuel Tank Vapor System -

Gasoline is extremely volatile in almost all environments, and even diesel is aromatic. Since these vapors can be flammable or noxious, they must be contained & routed to the engine to be burned. But t...
(Posted in: Diagrams)

VaporMgmtValve.jpg
3294 hits | 30.71 KB | Posted: 12/4/04
Vapor Management Valve (VMV)

The Fuel Tank Vapor System -

Gasoline is extremely volatile in almost all environments, and even diesel is aromatic. Since these vapors can be flammable or noxious, they must be contained & routed to the engine to be b...
(Posted in: Diagrams)

02Adjuster.JPG
3294 hits | 55.85 KB | Posted: 12/5/06
After buying new shoes (NAPA ~$25/set of 4), removing the tire, caliper, & rotor, the next step is to back off the adjuster star wheel by prying up. If it's stuck, use some pentrating oil, but don't contaminate the brakes. This releives the tension...
(Posted in: E-Brake Shoes)

AirbagCodes02.JPG
3298 hits | 63.24 KB | Posted: 10/19/08
SRS Airbag Codes for '02 CV

Others similar
(Posted in: Diagrams)

Sender & Gasket.JPG
3299 hits | 66 KB | Posted: 3/27/05
The "plenum chamber" gasket goes between the intake & the throttle-body elbow, and is replaced after cleaning the EGR passages.

The oil pressure sender will allow the gauge to actually work if its resistor on the back of the cluster is shorted.
(Posted in: Random Pics)

ParkBrakeVacValve.jpg
3300 hits | 74.9 KB | Posted: 11/7/05
Parking Brake Vacuum Release
(Posted in: Diagrams)

AOD's 2-door 85 Crown Vic 008.jpg
3303 hits | 119.19 KB | Posted: 6/27/05
(Posted in: 85 Crown Victoria 2-Door)

Piston Cleaning.jpg
3310 hits | 41.07 KB | Posted: 1/2/05
CAUTION: Do not use a caustic cleaning solution or a wire brush to clean pistons.

Remove deposits from the piston surfaces. Clean gum or varnish from the piston skirt, piston pins, and rings with solvent.

Clean the ring grooves with Piston Ring...
(Posted in: Diagrams)

FDM.jpg
3315 hits | 44.78 KB | Posted: 12/4/04
FDM
(Posted in: Diagrams)

Headliner11.JPG
3316 hits | 26.67 KB | Posted: 12/14/06
'94 Grand Marquis headliner on the L; '99 P71 on the R.
(Posted in: Headliner "Repair")

Fuel Pressures.jpg
3322 hits | 37.93 KB | Posted: 3/20/05
Fuel Pressures

NOTE:
Maximum fuel pressure is obtainable at WOT or the vacuum hose removed from the fuel pressure regulator.
(Posted in: Diagrams)

Track-lock installed50.JPG
3323 hits | 59.38 KB | Posted: 10/28/03
The track-lock and gears, finally installed.
(Posted in: 3.55 Track-lock install)

Crank Install 93.jpg
3325 hits | 74.48 KB | Posted: 1/2/05
Crank Install 93
(Posted in: Diagrams)

Main Cap Install 93.jpg
3329 hits | 84.8 KB | Posted: 1/2/05
Main Cap Install 93
(Posted in: Diagrams)

PIC03558.jpg
3330 hits | 82.02 KB | Posted: 8/31/06
(Posted in: Latest Pics)

Transmission removal.JPG
3331 hits | 62.91 KB | Posted: 12/5/05
To gain more access, we removed the transmission
(Posted in: PI Cams)

20180826_182101.jpg
3332 hits | 86.87 KB | Posted: 8/30/18
It's still driveable, but it's totalled, due to a Freestyle turning left (illegally) in front of me. I'll probably pull the engine/trans/PCM since they're still in great condition, and scrap the body.
(Posted in: Vicky)

ShiftScrsLoose.JPG
3351 hits | 48.53 KB | Posted: 3/13/16
This problem commonly affects '92-up truck (and other Ford/L/M) steering columns, but it's relatively easy to fix with a few drops of blue threadlocker if it's caught before the shifter breaks. These screws are #34 in the PREVious diagram.

See also...
(Posted in: Steering Column)

Courtesy Circuit 98.jpg
3359 hits | 48.87 KB | Posted: 1/2/05
Courtesy Circuit 98
(Posted in: Diagrams)