CompZonMap.jpg
3638 hits | 42.84 KB | Posted: 12/4/04
Compass Zones

Zone Setting

1. Insert an appropriate diameter rod, preferably non-metallic, into the right switch access hole underneath the compass module and gently press the RH switch for one to two seconds until ZONE and the current zone set...
(Posted in: Diagrams)

Headliner5.JPG
3649 hits | 62.8 KB | Posted: 12/7/06
Laid out like this, I can really see how dirty it is, especially near the A-pillars.
(Posted in: Headliner "Repair")

drift.jpg
3650 hits | 56.8 KB | Posted: 7/31/08
drift! haha
(Posted in: pics)

Motivator OLAP Burnout.jpg
3661 hits | 31.21 KB | Posted: 1/29/06
(Posted in: Motivational Panther Pictures)

EngineTrans3.JPG
3664 hits | 89.13 KB | Posted: 3/31/05
Engine assembled to transmission after changing trans input & output seals.
(Posted in: 2000 Engine Installation)

VaporValve.jpg
3676 hits | 37.78 KB | Posted: 1/11/05
Fuel Vapor & Rollover Valve

The Fuel Tank Vapor System -

Gasoline is extremely volatile in almost all environments, and even diesel is aromatic. Since these vapors can be flammable or noxious, they must be contained & routed to the engine to ...
(Posted in: Diagrams)

Exhaust93.jpg
3683 hits | 63.71 KB | Posted: 4/10/05
Exhaust 1993

Exhaust System Alignment

1. Raise and support the vehicle.
2. Check for loose, damaged, or missing heat shields. Install new heat shields as necessary. Check for any trapped foreign material between the heat shields and the ex...
(Posted in: Diagrams)

Buckle5.jpg
3683 hits | 76.39 KB | Posted: 1/15/06
Since I also wanted to wash the seat belts, I disassembled the buckle.
(Posted in: Seats & Belts)

Headliner3.JPG
3684 hits | 64.73 KB | Posted: 12/6/06
The headliner will fall into place on the package shelf & on the seats. It can then be positioned over the C-pillars & lifted into place.
(Posted in: Headliner "Repair")

Engine.jpg
3711 hits | 80.71 KB | Posted: 8/11/05
1. Intake Manifold Gasket (2 Req'd)
2. Intake Manifold
3. Water Temperature Indicator Sending Unit
4. Water Thermostat
5. O-Ring
6. Water Outlet Adapter
7. Bolt (2 Req'd)
8. Engine Coolant Temperature Sensor
9. Fuel Injection Supply Manifold...
(Posted in: Tech)

03 Crown Vic LX rear2.jpg
3715 hits | 60.04 KB | Posted: 3/13/04
Rear view. P71 dual exhaust soon. Rear fascia will be replaced with tinted Marauder rear panel and all red taillamps with black trim. Black bumper inserts too.
(Posted in: 2003 CV LX P74 stock as purchased)

TransTCInstall4R70W.jpg
3728 hits | 21.63 KB | Posted: 4/8/05
Torque Converter Installation on 4R70W Transmission

Position the torque converter to the transmission. Align the converter to the front pump by rotating and pushing it inward, until full engagement is made. Install the Torque Converter Holding Too...
(Posted in: 2000 Engine Installation)

Engine Bay.jpg
3732 hits | 63.31 KB | Posted: 9/5/04
Engine bay
(Posted in: Vicky)

CoilFix.JPG
3743 hits | 63.92 KB | Posted: 11/6/06
This is what I had to do after the #6 plug blew out of the head at 2AM Sunday 1,000 miles into a 1,400-mile trip to get the car home. The spark plug is glued in with CarGo QuikSteel epoxy putty, and held down with a plug socket & 3" extension. Then...
(Posted in: Spark Plug)

Cam Sequence.jpg
3748 hits | 28.05 KB | Posted: 1/2/05
3. Install and seat camshaft cap cluster assemblies. Hand-start 14 bolts.

NOTE: Each camshaft cap cluster assembly is tightened individually.

4. Tighten camshaft cap cluster retaining bolts in sequence to 8-12 N-m (6.0-8.8 lb-ft).

5. Loosen...
(Posted in: Diagrams)

Buckle3.jpg
3752 hits | 55.77 KB | Posted: 1/15/06
Since I also wanted to wash the seat belts, I disassembled the buckle. Note that the passenger buckle cover does NOT have the notch visible here for the warning switch, so this cover must return to this belt. Same for the black latch inside, and it...
(Posted in: Seats & Belts)

AOD's 2-door 85 Crown Vic 010.jpg
3769 hits | 113.34 KB | Posted: 6/27/05
(Posted in: 85 Crown Victoria 2-Door)

Cluster04Marauder.JPG
3769 hits | 92.54 KB | Posted: 6/30/09
SOLD '04 Marauder Instrument Cluster
(Posted in: SOLD)

a03.JPG
3775 hits | 91.61 KB | Posted: 1/23/05
(Posted in: Engine Donor & Removal)

Leak.jpg
3803 hits | 54.21 KB | Posted: 2/8/06
This is a common problem for all '92-98 Panthers. Water draining from the A/C system runs out under the rubber flap & then back inside the firewall under the passenger front carpet & collects in the R rear footwell.
(Posted in: Rain Leak)

Cam Removal.jpg
3806 hits | 70.29 KB | Posted: 1/2/05
Cam Removal
(Posted in: Diagrams)

FPR Cutaway.jpg
3824 hits | 48.26 KB | Posted: 3/19/05
FPR

The fuel pressure regulator is attached to the fuel supply manifold assembly downstream of the fuel injectors. It regulates the fuel pressure supplied to the injectors. The regulator is a diaphragm-operated relief valve in which one side of th...
(Posted in: Diagrams)

EmissionsLabel.JPG
3841 hits | 73.79 KB | Posted: 2/7/07
Emissions Label
(Posted in: 99 P71)

Radio 92GMPS.jpg
3854 hits | 61.33 KB | Posted: 1/27/05
Radio 92 Grand Marquis Premium Sound
(Posted in: Diagrams)

71 Honda CB500 Clubman Bar Install 8-19-07 007.jpg
3857 hits | 127.67 KB | Posted: 8/19/07
(Posted in: 71 Honda CB500)

Fuel Injector Types.jpg
3865 hits | 29.84 KB | Posted: 3/19/05
Fuel Injector Types

See also:
. [url=http://www.supermotors.net/registry/media/724074][img]http://...
(Posted in: Diagrams)

Lubes94.jpg
3898 hits | 27.7 KB | Posted: 3/20/05
Recommended Lubricants 1994 CV, GM, & TC
(Posted in: Diagrams)

Buckle4.jpg
3917 hits | 58.16 KB | Posted: 1/15/06
Slide the cover forward, keeping the button with it, then lift them off the buckle. Note that the cover, the button, the black latch, & its spring are specific to side; the driver's parts are all built to fit with the warning switch, so as similar a...
(Posted in: Seats & Belts)

Valve Stem Removal.jpg
3919 hits | 42.78 KB | Posted: 1/2/05
Valve Stem Removal
(Posted in: Diagrams)

01Shoes.JPG
3930 hits | 59.5 KB | Posted: 12/5/06
My e-brake pedal had NO resistance, and when I pulled the rear rotors, I found why: the friction material is gone. Also, the drums are rusty because there was no friction material wear against them.
(Posted in: E-Brake Shoes)

i01.JPG
3935 hits | 96.14 KB | Posted: 1/28/05
The semicircular groove at the back of the intake journal is the groove for the EGR, which is packed solid with exhaust soot. It sets a code for "insufficient EGR flow" and can cause the engine to run hot, or even damage the pistons, so it has to be...
(Posted in: Engine Donor & Removal)

17 Leak.JPG
3938 hits | 42.51 KB | Posted: 5/16/05
Fluid leaks out of the slip-yoke's vent hole in the center behind the U-joint, and drips off the bottom. It also slings onto the underbody. The tube is dry just behind the yellow seal.

The black thing at the L center of the photo is the VSS.
(Posted in: Forced Lube)

GasTank8.JPG
3941 hits | 70.88 KB | Posted: 4/21/05
A can of B-12 got it pretty clean, and the anti-theft valve moves freely now.
(Posted in: 2000 Engine Installation)

RadioPinout01.jpg
3969 hits | 35.84 KB | Posted: 5/1/05
Radio Pinout 2001
(Posted in: Diagrams)

DiagSystem98.jpg
3974 hits | 34.06 KB | Posted: 3/17/05
The diagnostic communication network:
> consists of a single wire, Circuit 70 (LB/W).
> provides a common link for communication to an off-board tester through the data link connector (DLC) located under the instrument panel (04320) to the right of...
(Posted in: Diagrams)

z0500933.JPG
4009 hits | 75.21 KB | Posted: 1/27/10
(Posted in: 85 Crown Victoria 2-Door)

Biltmore Estate 5-29-06 004.jpg
4020 hits | 58.7 KB | Posted: 7/23/06
(Posted in: Biltmore Estate 5-31-06)

4.6L GT crate engine.jpg
4026 hits | 32.72 KB | Posted: 4/2/05
Crate engine from ebay. Fits '99-04 Mustang
(Posted in: Random Pics)

18Done.JPG
4028 hits | 91.03 KB | Posted: 11/21/06
Once I get the other 7 done, I'll replace the alternator connector.


UPDATE: Turns out I won't be blowing any more plugs out of this engine - I totalled the car. But the TimeSert kit turned out to be pretty lucrative. I rented it out to local mech...
(Posted in: Spark Plug)

TorqueConverter94.jpg
4029 hits | 53.74 KB | Posted: 5/8/05
Torque Converter for AODE

. [url=http://www.supermotors.net/registry/media/203172][img]http://www.su...
(Posted in: Diagrams)

2003 CrownVic body.JPG
4035 hits | 46.62 KB | Posted: 9/4/06
2003 Crown Vic Body Specs
(Posted in: Diagrams)

00CVDashConnectors.jpg
4049 hits | 64.86 KB | Posted: 12/4/04
Dash Connectors 00 CV
(Posted in: Diagrams)

5.0 SEFI EEC-IV Wire Diagram.jpg
4062 hits | 62.48 KB | Posted: 4/11/07
(Posted in: Wire Diagrams)

Buckle2.JPG
4072 hits | 64.11 KB | Posted: 1/15/06
Since I also wanted to wash the seat belts, I disassembled the buckle.

When one tab is out, it's sometimes possible to push it up, and the other may come out. If not, repeat the process on the other tab.
(Posted in: Seats & Belts)

Crank Position.jpg
4081 hits | 42.17 KB | Posted: 1/2/05
Crank Position for #1 TDC
(Posted in: Diagrams)