SuperMotors SuperMotors SUPERMOTORS Search: try “orange Bronco on 35s”
Join
Home/ Registry/ Ford/ Bronco/ 1992-1996/ “Lil Mule”/ Front End Rebuild supermotors.net/registry/4580/28512

Album section

Front End Rebuild

From 1995 Ford Bronco “Lil Mule”, documented by 95LilMule.

39 photos
← Back to this vehicle
1995 Ford Bronco - The front corner of a dark-blue vehicle raised on a jack stand and wood blocks with the wheel removed, exposing the coil spring, twin shock… 1995 Ford Bronco - A front hub torn down on a lifted 4x4: the wheel, hub and locking hub are off, leaving the splined axle shaft stub sticking out through the… 1995 Ford Bronco - A disassembled front axle laid out on cardboard on a garage floor: rotor and hub assembly with wheel studs at left, spindle bearings, snap… 1995 Ford Bronco - Overhead shot of a front axle teardown spread on cardboard: the rotor-and-hub with wheel studs at right, a splined axle shaft with U-joint… 1995 Ford Bronco - A front steering knuckle stripped bare on a lifted 4x4, spindle, hub and rotor removed, leaving the bolt studs and open bore visible, with… 1995 Ford Bronco - Wider view of a front-end rebuild on a lifted truck: the bare steering knuckle sits on wood cribbing with the spindle and hub removed, next… 1995 Ford Bronco - A removed axle tube/shaft assembly with a rubber boot rests on a plank workbench in a garage, with U-joint caps and a shop rag beside it an… 1995 Ford Bronco - A removed front steering knuckle stands on the garage floor against wood cribbing, with its upper and lower ball joints and threaded studs… 1995 Ford Bronco - Close-up under a truck's front suspension showing the coil spring, red-booted shock absorber, upper and lower ball joints and axle bracket… 1995 Ford Bronco - A removed steering knuckle/spindle standing on a garage floor with its upper and lower ball joints still installed, propped against wood bl… 1995 Ford Bronco - Front suspension torn down with the wheel and axle shaft removed, showing the coil spring, red-booted shock, tie rod end, brake hose and st… 1995 Ford Bronco - Underbody shot of the rear ends of two rusty radius arms, each with the old bushing gone and a bare sleeve/washer left in the mounting eye… 1995 Ford Bronco - A new red Energy Suspension polyurethane bushing with metal sleeve sitting on cardboard next to its yellow and red Energy Suspension Polyur… 1995 Ford Bronco - Underbody close-up of a rusty suspension link or radius arm eye with the rubber bushing burned/torn out, leaving a hollow ring and a wooden… 1995 Ford Bronco - Extreme close-up of a radius arm's rear bushing eye, freshly cleaned and bare, resting on a wood cribbing block under a truck. A 6-ton vehi… 1995 Ford Bronco - Front view under a 4x4 mid-teardown, with the axle housing, radius arms and steering linkage exposed and the truck resting on stacked wood… 1995 Ford Bronco - Tight under-vehicle shot of a repainted gray radius arm with its bushing eye empty, resting on a wood cribbing block beneath the rusty fram… 1995 Ford Bronco - Underside view of a freshly painted black radius arm mounted in its frame bracket with a new red polyurethane bushing and washer at the piv… 1995 Ford Bronco - Underside view of a Ford Bronco showing the front differential cover, a red-bodied shock absorber with a large hex bolt, and a coil spring,… 1995 Ford Bronco - Close underside view of a newly installed red polyurethane sway-bar bushing clamped in its bracket against the frame, with the fresh bolt a… 1995 Ford Bronco - Two old rubber radius arm bushing halves lying on a concrete garage floor after removal, the taller cone-shaped piece cracked and distorted… 1995 Ford Bronco - Two worn rubber suspension bushings on a sunlit concrete floor, the right-hand one molded with "LEFT HAND" text and a part number and badly… 1995 Ford Bronco - A removed differential third-member/carrier with its pinion yoke still attached, set nose-down in a green oil drain pan on shop towels to d… 1995 Ford Bronco - Side view of a grimy cast-iron differential housing sitting on a pink shop towel and wood block on a workbench, with the pinion seal remove… 1995 Ford Bronco - Close-up of a pinion seal replacement: the removed differential housing rests on wood blocks with the pinion yoke and nut visible, while a… 1995 Ford Bronco - A removed cast-iron differential center section rests on a red shop towel and wood blocks, ring-gear opening stuffed with a white rag and t… 1995 Ford Bronco - A bare steel anti-sway bar lies on a garage floor with its hardware laid out above it on a white towel: red polyurethane bushings, black ru… 1995 Ford Bronco - Close overhead view of sway-bar hardware arranged on a greasy white shop towel: red polyurethane bushings pressed into brackets and forged… 1995 Ford Bronco - Low front view under a lifted truck on jack stands and wood cribbing, showing the Dana front axle housing, coil-spring/radius-arm suspensio… 1995 Ford Bronco - Close-up of a solid front axle and steering assembly on a 4x4, resting on a wooden block. It shows the knuckle and splined stub, brake back… 1995 Ford Bronco - Close-up of a front hub and drilled brake rotor with the wheel removed, showing the splined axle stub, wheel studs, coil spring, sway bar w… 1995 Ford Bronco - Underbody view of front suspension showing a black sway bar with red poly bushings, tie rod and adjustable steering linkage over wood block… 1995 Ford Bronco - Underside view of a vehicle's front suspension and axle photographed while supported on a jack stand and a stacked wooden block. Visible co… 1995 Ford Bronco - Close-up of a front suspension and drilled brake rotor with an exposed splined spindle/stub axle, showing a red coil spring, red polyuretha… 1995 Ford Bronco - Front suspension and brake assembly of a vehicle raised on a jack stand and wooden blocks, showing a drilled rotor, wheel hub with locking… 1995 Ford Bronco - Underside view of a lifted 4x4's front axle and steering, showing a heavy-duty tie rod and drag link with red-booted joints, plus the steer… 1995 Ford Bronco - Low-angle underside view of a lifted 4x4 front axle showing the steering linkage with red polyurethane tie-rod end boots, a solid front dif… 1995 Ford Bronco - Underside view of a solid front axle showing the steering linkage, including a red-booted steering stabilizer, tie rod ends with red polyur… 1995 Ford Bronco - Close-up underside view of a lifted 4x4's front suspension and steering, showing a red-bo.oted steering stabilizer, tie rod/drag link with…