Trailer Connector Color Codes 4, 6 & 7 pins

Transmission Range (TR) Sensor (MLPS) Alignment Tool

Auto Lock Hubs D44 1996
1 Cap, 2 Hub Body, 3 Snap Ring, 4 Plastic Thrust Washer, 5 Cam Assembly (Part of 1K105), 6 Wheel Retainer (Nut), 7 Wheel Retainer Key, 8 Steel Thrust Washer, 9 Splined Thrust Washer, 10 Lock Ring, 11 cap screws (3)
A. While Rotating Front Disc Brake Hub & Rotor, Tighten Wheel Retainer (Nut) to 68 N-m (50 Lb-Ft) to Seat Wheel Bearings. Back Nut Off 90 Degrees (1/4 Turn). Tighten to 1.8 N-m (16 Lb-In).
B. Tighten to 4-6 N-m (35-53 Lb-In)

Removal
1 Separate cap from body assembly by removing the three capscrews, using Torx® bit TX25 or equivalent, from the cap.
2 Remove cap.
3 Remove the lock ring seated in the groove of the front disc brake hub and rotor (1102).
4 Remove the body assembly from the front disc brake hub and rotor.
5 Remove C-washer or snap ring from stub shaft groove.
6 Remove spacers (three thrust washers) from shaft.
7 Remove cam assembly. Pull to remove.
8 If front disc brake hub and rotor and front wheel spindle (3105) are to be removed, refer to Wheel Grease Seal and Bearing, Front Replacement and Repacking in the Disassembly and Assembly portion of this section.

Roof Crack Repair Kit; TSB #962011

Rear Window Defrost Control 1996

Rear Window Defoster Sw Schematic 1996

96 Keyless Entry Antenna Plug (C3)

5.0 PCV oil baffle pic

Bronco depictions

front capt/bucket seat back latch 96

Latch 62648, #5 is Bolt and Washer, but is part of the latch, (Part of 6264

RKE Module 96

1996 Bronco 5.0 Firing Order Sticker

96 5.0 Plug Wire Routing on Driver's Side

96 5.0 Plug Wire Routing on Driver's Side low

96 5.0 Plug Wire Routing - distributor view

96 5.0 Plug Wire Routing on Passenger's Side; below distributor

96 5.0 Plug Wire Routing on Driver's side, above distributor

KYB Shock Rust

5.0 Plug Wire Routing Diagram

"Back Window Glass Run"; Ford PN 422A20.

92upheadlamprem

045B34 Console Mounting Rear Bracket
for 1996; overhead console F4TB-98519A58

Bronco Snow Ad

96 Bronco Sticker

Bronco Illustration1

Bronco Illustration 2

Bronco Illustration 3

92+ Spout Connector Location for 5.0/5.8

PSOM Pin-Outs (Internal)

Differential Pressure Feedback (DPFE) Location pic in a 96 5.0; Silver Rectangular item, driver's side next to distributor - MIESK5 NOTE: only 95 5.8L California models & all 96 have the DPFE Sensor instead of EGR Valve Position Sensor (EVP)

E4OD Transmission Selector Indicator Removal in 92-96

O2 Sensor Locations in a 96 5.8

O2 Sensor Locations in a 96 5.0

Tailgate Torsion Bar Location (red) pic, External in a 96

Power Door Lock Parts Break-Out Diagram in an 87

O2 Sensor Locations in a 96 5.0

spout connector location in 92-96

Tire Carrier, Swing-Away, Type 3 (90-96) Parts Break-Out Diagram w/Ford Part Numbers

Carrier, Tire [1] F2TZ 1433 A 32851
Support, [2] FOTZ 1A429 A 4674
Hinge, Upper [3] E7TZ 1478 A
Hinge, Lower [4] E7TZ 1479 A 6023
Hinge Pin (2) [5] D8TZ 1487 A 1406 (2)
Carrier Bushing [6] N803515-S
Lock, Wheel [7] FOTZ 1A043 B 2502
Nut, Retaining [8] E8AZ 1012 A 64
Bumper, Carrier [9] D8TZ 1A366 B 1133
Pad, Scuff [10] F1TZ 9847104 A 950
Sleeve, Carrier Arm [11] E8TZ 1A477 A 1381
Reinforcement[12] F1TZ 1A401 A 5194
Support [13] F2TZ 1469 A 1947
Latch [14] F2TZ 1A398 A 2487
Rod, Lock [15] FOTZ 1A459 A 857
Handle, Lock [16] F2TZ 1A360 A 2741
Bushing & Bolt Kit [17] FOTZ1400A 1472
Spring, Lever [18] FOTZ 1A361 A 468

Idle Air Control (IAC) Sludge; Poor Idle TSB 91-10-9 for 89-91 Bronco & F Series & many others

Idle Air Control (IAC) Sludge; Poor Idle TSB 91-10-9 for 89-91 Bronco & F Series & many others PAGE 7

Idle Air Control (IAC) Sludge; Poor Idle TSB 91-10-9 for 89-91 Bronco & F Series & many others Page 2

Idle Air Control (IAC) Sludge; Poor Idle TSB 91-10-9 for 89-91 Bronco & F Series & many others Page 3

Idle Air Control (IAC) Sludge; Poor Idle TSB 91-10-9 for 89-91 Bronco & F Series & many others Page 4

Idle Air Control (IAC) Sludge; Poor Idle TSB 91-10-9 for 89-91 Bronco & F Series & many others Page 5

Idle Air Control (IAC) Sludge; Poor Idle TSB 91-10-9 for 89-91 Bronco & F Series & many others Page 6

Borg Warner 1356 Electric Shift On The Fly (ESOF) & Manual Shift Transfer Case Parts Break-Out Diagram
1 1000183041 BOLT - PTO COVER
2 1356565011 FRONT CASE HALF (MECH. SHIFT - PTO)
2 1356565005 FRONT CASE HALF (MECH. SHIFT w/o PTO)
2 1356565006 FRONT CASE HALF (ELEC. SHIFT)
3 1356539003 REAR CASE HALF (MECH. SHIFT)
3 1356539004 REAR CASE HALF (ELEC. SHIFT)
4 1356566003 BEARING CAP ASSY
5 1300183017 BOLT - WASHER
6 1900149002 NUT - REAR OUTPUT SHAFT
7 1000047015 WASHER (REAR YOKE/FLANGE)
8 1300016002 OIL SEAL - REAR YOKE/FLANGE (BOLT-ON)
9 1356531004 REAR FLANGE
10 1345035001 DEFLECTOR - SLINGER
11 1900044012 SEAL - REAR FLANGE (BOLT-ON)
13 1360183008 BOLT - 1987-88 (4 REQ.)
13 1300183017 BOLT/WASHER - 1989 & LATER
14 1356531002 REAR YOKE
15 1356016001 OIL SEAL - SLIP YOKE SPLINE
16 1900044013 REAR SEAL - SLIP YOKE
17 1356127001 BUSHING - REAR SLIP YOKE
18 1300146003 STUD
19 1356614002 SPEEDO PLATE
20 1356566012 TAIL HOUSING ASSY
21 1300052003 PLUG
22 1300183008 BOLT 1987-88 (12 REQ.)
22 1300183017 BOLT/WASHER - 1989-ON (12 REQ.)
23 SCE2012 NEEDLE BEARING
24 1000012002 MAGNET
25 1300043005 DOWEL PIN
26 1900044012 SEAL - FRONT OUTPUT
27 1300035001 SLINGER
28 1356531001 YOKE ASSY
29 1000016002 OIL SEAL
30 1000047015 WASHER
31 1900149002 NUT - FRONT OUTPUT SHAFT
32 1300183019 SET SCREW
33 1300140007 SWITCH - 4WD INDICATOR
34 1300072001 BARB - BREATHER
35 1900044012 SEAL - INPUT
36 PTO-55 GASKET - PTO COVER
38/64 1356235001 SHIFT FORK PADS (RANGE FORK) - (2 REQ.)
39/52 4400596001R SHIFT FORK ASSY (RANGE)
40 1350040002 RETAINER - ALSO SERVICED IN #39
41/54 1345235001 SHIFT FORK PADS (MODE FORK) - (2 REQ.)
42/55 1356096007 SHIFT FORK - NEW STYLE ALL PLASTIC
43/57 1350156002 RETURN SPRING
44/56 1350100001 SHIFT RAIL
45 1356127008 BUSHING - SHIFT CAM
46 1356599001 SHIFT CAM - LATE STYLE SPLINED
47 1356598008 SHIFT LEVER - CURVED - NO SHAFT
47 1356598009 SHIFT LEVER - STRAIGHT - SPLINED SHAFT
47 1356598007 SHIFT LEVER - STRAIGHT - SET SCREW SHAFT
47 1356598006 SHIFT LEVER - STRAIGHT w/o SHAFT
47 1356122001 SHIFT SHAFT ONLY
48 1300016001 OIL SEAL
49 1345056002 RETAINING CLIP
50/62 1350043001 RETAINER PIN - ALSO SERVICED IN #39
51/63 1352127001 CAM ROLLER
58 0011503949 BOLT - SHIFT MOTOR
59 1356640003 SHIFT MOTOR
60 1300044001 OIL SEAL - SHIFT SHAFT - (ELEC. SHIFT)
61 1300127002 SLEEVE BEARING
65 1356122007 SHIFT SHAFT - (ELEC. SHIFT)
66 1356053005 SPACER - SHIFT SHAFT
67 1356156006 SPRING - TORSIONAL
68 1356099007 CAM - (ELEC. SHIFT)
69 1356056003 BRACKET WIRING HARNESS
70 11505117 BOLT - WIRING BRACKET
71 11505117 BOLT - SHIFT MOTOR
72 1000141014 O-RING
73 1350140002 SENSOR - SPEED
74 1300139010 SNAP RING
75 1345193005 WASHER
76 1345130001 BALL BEARING - FRONT OUTPUT
77 T86-7.5 SNAP RING
78 1356171008 SHAFT - FRONT OUTPUT
79 1356144002 SPROCKET - DRIVEN
80 13797 HV012 DRIVE CHAIN
81 1356410003 PLANETARY UPDATE KIT - NON-PTO - CAN USE 1356410004
81 1356410004 PLANETARY UPDATE KIT - PTO
82 1300139009 RETAINING RING - INPUT BEARING
83 1300130001 BEARING - INPUT SHAFT
84 1300139010 RETAINING RING - PTO DRIVE GEAR
85 1356070002 GEAR - PTO DRIVE
86 1356162002 RING GEAR - BEFORE 6/5/95 - USE 1356410003/1356410004
87 1300139012 RETAINING RING - PLANETARY RING
88 1356659009 PLANETARY ASSY - INPUT NON-PTO - AFTER 6/5/95
88 1356659010 PLANETARY ASSY - INPUT - PTO - AFTER 6/5/95
88 1356659007 PLANETARY ASSY - BEFORE 6/5/95 - USE 1356410003 NON-PTO
88 1356659008 PLANETARY ASSY - BEFORE 6/5/95 - USE 1356410004 - PTO
89 1356089001R RANGE SHIFT HUB - EARLY BEFORE 6/5/96
89 1356089003R RANGE SHIFT HUB - LATE AFTER 6/5/96
90 1300132012 NEEDLE BEARING
91 1345127002 BUSHING - INPUT PILOT
92 1345156004 PUMP PIN SPRING
93 1345043007 PUMP KIT (2 REQ.)
94 1356171007R MAIN SHAFT - REAR SLIP YOKE
94 1356171009 MAIN SHAFT - REAR BOLT ON YOKE
94 1356171013 MAIN SHAFT - REAR BOLT ON FLANGE
95 1000109001 BALL - SPEEDO GEAR
96 1345039007 PUMP COVER - FRONT
97 1345097004R PUMP HOUSING
98 1345039005 PUMP COVER, REAR
99 1356056004 PUMP RETAINER
100 1345183003 BOLT - PUMP ASSY
101 1356144003 SPROCKET - DRIVE
102 1345238001 OIL STRAINER
103 1356034001 HOSE
104 1345056005 CLAMP - PUMP HOSE
106 1356055003 COLLAR - LOCK UP (ELEC. SHIFT)
107 1350156007 SPRING SLEEVE RETURN
108 1356089002 HUB REDUCTION 9 SPLINE
109 1000139041 RING, RETAINING
110 1356090004 HUB - SHIFT COLLAR (MECH. SHIFT)
111 1356212002 CLUTCH HOUSING
112 1000139027 SNAP RING
113 1356640002 COIL ASSY - CLUTCH
114 207 BEARING
115 1000139027 SNAP RING
116 1356053003 SPEEDO GEAR RETAINER
117/129 T18-169 SPEEDO GEAR (7T)
117/129 T18-169D SPEEDO GEAR (8T)
119 1356055001 COLLAR - LOCK UP (MECH. SHIFT)
120 1350156007 SLEEVE RETURN SPRING
121 1356089002 HUB - LOCK UP (ELEC. SHIFT)
122 1000139041 RETAINING RING
123 1356090002 HUB - SHIFT COLLAR (ELEC. SHIFT)
124 1300139027 SNAP RING
125 1345130001 BALL BEARING - REAR MAIN SHAFT
126 1300139027 SNAP RING
128 1356053003 RETAINER - SPEEDO GEAR
T1356R
BEARING, SEAL & GASKET KIT
K1356 GASKET & SEAL KIT
SP1356-50 SMALL PARTS KIT
PK1356 OIL PUMP KIT

Malfunction Indicator Light (MIL) ("Check Engine Light") Illumination; The "Check Engine" lamp may illuminate and a Code P0420 may be stored in memory. There may be no driveability concerns present.TSB 96-15-13 for 96 Bronco, F Series & Econoline w/5.0L Page 1 of 4